NHTSA complaint #11759871

Owner complaint summary

Vehicle's Auto Start-Stop system shut the engine off while stopped at a red light in [XXX], in rainy conditions in late XXX at approximately 29,000 miles. When the brake was released after the light turned green, the engine did not restart, leaving it stopped in the travel lane in live traffic. The driver had to use a portable jump starter to get it running again. This was not isolated — repeated failure-to-start incidents in prior weeks had already prompted carrying a portable jump starter in the vehicle. At the time we believed this was a failing 12V battery. The original battery was replaced XXX with a new aftermarket AGM battery. Despite that replacement, the vehicle has continued to have multiple complete battery drain if left parked for multiple days (but less than a week), indicating the restart failures were likely caused by an underlying parasitic electrical draw rather than a simple worn-out battery. Subaru's own Technical Service Bulletin 07-199-21R, "Measurement of Dark Current (Standby Current Draw)," describes this exact failure pattern (batteries/vehicles going dead over time due to standby current traced to the VDC module and/or Power Rear Gate control module) for this model and model-year range. A pending federal class-action lawsuit, [XXX] v. Subaru of America, Inc., Case No. XXX (D.N.J., filed XXX), alleges an electrical-system defect preventing one or more control modules from entering a proper low-power sleep state, causing parasitic battery drain, and specifically names 2021-2022 Outback vehicles. We are concerned this defect can cause the Auto Start-Stop system to fail to restart the engine at a stop in live traffic, creating a real risk of being rear-ended or blocking an intersection, as happened in the incident described above. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)