Chrysler Pacifica 2022

On three separate occasions (December 2023-February 2024), while driving in temperatures below freezing, our 2022 Chrysler Pacifica Hybrid dashboard gave the following warning, along side the illumination of a red turtle warning light: "Stop Safely. Vehicle will shut off soon." The vehicle then lost the ability to accelerate, and the speed dropped significantly and immediately. Two of the three times, my one and three year old were in the vehicle and there was no shoulder on the 50mph road we were traveling on after sunset. Fortunately, the three times this happened, we were less than a half mile from our home and we coasted downhill to the bottom of our driveway. Our vehicle has now been at a certified Chrysler dealership for three full business days, and the technician "has no idea what is wrong," "is still working on it," "has no idea how long it will take to fix," and "has no rental or loaner cars available" for our family while we wait for our family's mode of Transportation to be returned. They claim they are unable to recreate the issue, so they cannot fix it. We showed them a picture of the dashboard, but that is not enough for them. It is currently 72 degrees in Dayton, OH, and the issue has never occurred in temperatures above 30 degrees. Thus, I doubt they will be able to "recreate" the issue until next winter. They've offered no other options or resolution until they can "recreate the issue."

I was traveling on the freeway at approximately 65 miles per hour. I slowed to approximately 50 miles per hour to pass a disabled vehicle and began accelerating again when the dash displayed a message that said "Stop Safely- Vehicle will Shut off soon" the check engine light, a red turtle light also lit up. I had to make a quick maneuver to the far right lane putting myself and other vehicles at risk to avoid the car shutting down in the middle of the freeway. I wanted to get closer to an exit so I continued driving slowly on the shoulder. The wouldn’t accelerate, so whatever speed I let it get down to was the fastest it would go. At the exit I was concerned I wouldn’t have enough power to make it up the hill so I shut off the car. I let it sit for a couple of minutes and then turned it back on. It turned on with the check engine light still on . I then drove it straight to the dealership using surface streets and keeping my speed around 40-45 miles per hour. This was the second time this vehicle has experience this kind of loss of power. The first time happened in July 2024 and resulted in a full transmission replacement. This incident constitutes a dangerous loss of motive power at highway speeds. The failure mode appears identical to the issues described in NHTSA Safety Recall 23V-010 (Chrysler Recall 03A), yet this vehicle has already had a full transmission replacement for this exact issue in the past.

Ever since delivery of our vehicle it would seem to have a hard shift between the electric and gas motor. Recently, we were driving one morning and noticed that when the gas engine kicked in, the RPM’s were much higher than usual. Later that day we received the “Stop Safely the Vehicle Will Shut Off Soon” message along with a check engine light. Shortly thereafter the vehicle went into limp mode. We are very lucky this happened in town as opposed to on the highway or in a remote area where this would pose an even more serious safety risk. Especially with young children on board. We then brought the vehicle to the nearby dealer where they found P0A43-00 “Drive Motor "A" Position Sensor” and C0063-9A “ Yaw Rate Sensor-Component or System Operating Conditions” codes present. After nearly a week of troubleshooting and opening up a “STAR” case, the dealership is now in the process of acquiring and replacing the transmission on our vehicle. This seems to be related to the recent recall 03A “Loss of Motive Power” and Chrysler TSB 21-008-23 affecting the internal transmission wiring connector. Our recall was completed promptly after issuance but this did not address the underlying issue of the internal transmission wiring connector. Our van is just over one year old and has under 21,000 miles on it. Needless to say this is unacceptable for a vehicle of this age, use, and especially MSRP! We purchased this vehicle as a safe option for our family and now we have lost confidence.

Subject: Urgent Safety Concern – Chrysler Pacifica Hybrid (VIN: [XXX] ) Dear NHTSA, I am writing to report a serious safety issue with my 2022 Chrysler Pacifica Hybrid (VIN: [XXX] ). The vehicle experiences sudden power loss due to the following error codes: P079A-00 (transmission issue), P0A43-00 (hybrid battery issue), and P0A7D-00 (battery voltage issue). These problems have nearly caused accidents, including: On the highway: Power loss while overtaking, leaving me in a dangerous situation. In city traffic: Repeated power loss, almost causing collisions. The issues are well-documented among Pacifica Hybrid owners in the USA. NHTSA has received numerous complaints, and there are active class-action lawsuits due to unresolved problems. My vehicle was involved in a minor collision in the USA, classified as "clear title" (cosmetic damage only, no impact on the drivetrain or battery). Repairs were done professionally, and there is no connection to the current issues. I have contacted Chrysler and the authorized service center in Berlin, but received no response. This issue poses a direct safety risk, and I urge NHTSA to investigate and ensure a permanent solution. Attached: Error codes and incident descriptions. Correspondence with Chrysler and the service center. Documentation of the collision and repairs. Thank you for your attention. I look forward to your prompt response. Sincerely, [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On July 19, 2026, I was driving my 2022 Chrysler Pacifica Hybrid on E-470 at approximately 75 mph. Without warning, the dashboard displayed "Stop Safely. Vehicle Will Shut Off Soon," and the amber check engine light illuminated. At the same time, the vehicle immediately lost all motor power, began slowing, and did not respond to accelerator input. There were six occupants in the vehicle, including four young children. I was traveling on a busy six-lane highway with little to no shoulder. I had to maneuver across traffic without motor power to reach the side of the road, placing all six occupants at immediate risk. After turning the vehicle off for about five minutes, I restarted it. Only the check engine light remained illuminated, and the vehicle appeared to have normal power. We continued driving at 55–65 mph to reach a safer location. About 10 minutes later, the same warning appeared and the vehicle again lost all motor power. This time we were on a steep, busy exit ramp and had to immediately pull off as the vehicle rapidly lost speed, again placing all six occupants at risk. After waiting about five minutes, we restarted the vehicle, drove it to a safe location, and had it towed to a dealership. The dealership was closed, so the cause of the failure has not yet been determined. This incident created an extremely dangerous situation, and we narrowly avoided a collision on the interstate. A sudden loss of propulsion at highway speeds without warning is a serious safety hazard that warrants investigation and consideration for a recall.

While driving 75MPH, the vehicle shut down with a message to pull over. All acceleration was lost. We had to navigate, without warning, across 3 lanes of traffic to pull over on the right side of the highway. This was EXTREMELY unsafe as we were slowing down and essentially cutting off other vehicles who were honking at us as this was a traffic hazard. All 6 members of my family were in the vehicle. We had this happen another 3 times before arriving home. I took it to my local dealer, who could not replicate it. They performed a software update, which I have since learned would NEVER fix this problem. We had it happen to us 5 more times, so I took it to another dealership, who initially could not replicate it. In all cases, we had the following check engine light codes be triggered. I have screen shots of them from my personal OBDII reader: P0A43 "Drive Motor 'A' Position Sensor Circuit Intermittent", C2225 "Status: MIL - PCM Disabled EDU: No Sub Type Information". After doing my own reading, it seemed many others have experienced the exact same symptoms and it has required a transmission repair/replace. I also learned most people had a battery charge on the high voltage battery (as this is a plug-in hybrid) when the vehicle shuts down. I charged my van, took it for a ride at 75MPH and it occurred within the first mile. I took it back to the dealership, and at this point, I refuse to drive it until the hardware fix happens. It seems like this should be a recall for all vehicles that can have this problem. It is EXTREMELY unsafe as it occurs at 70MPH+ speeds.

Number of days your vehicle is down: indefinitely as of now there is no fix according to the dealership parts are at least 10 weeks out with them not knowing how to do the install once parts arrive Number of Repair Attempts: there is no fix as of now but the vehicle has broken down 4 times parts for the transmission are on back order (at least ten weeks) and they do not know how to install the parts once they arrive First Repair Attempt Date and Problem: June 10, 2025 The van showed a message saying pull over as the vehicle will stop while we were on the highway heading to my daughters graduation. Initially. We were able to pull over that time and stop driving before the car turned off. we took the vehicle in and they inspected it for the recall. Most recently, the vehicle did it again on the highway. I was not being able to pull all the way over prior to the vehicle, losing power and stopping in the middle of the highway with my children inside. Voice of the Customer / Complaint: as of now there is no timetable for us to be able to return driving the vehicle which is extremely unsafe. We purposely got a seven passenger van to transport our entire family, and at this point we have no way to do. So. The dealership says they are unable to give us a loaner for that, and we are getting no assistance with this with no timetable. As far as when the vehicle will be fixed. Therefore, I’m requesting a buyback of the vehicle so that we can get something to transport our family as the vehicle is down. I am still having to pay for the car note without having anything to Show for it. I cannot drive it as I don’t know when it will shut off. It is currently sitting at the dealer.

Dash message "Stop safely vehicle will shut off soon" included a red exclamation mark in the middle with a red triangle and a turtle in the bottom right. A yellow reduced speed type indicator in the top right and a check engine light all at the same time. Also a chime sounded. This occured in town moving around 35 mph. Dealer stated this exact VIN had already received a rebuilt trans around 50k miles from another dealer. Took dealer 2+ months to repair, and had to call many many times to encourage them to push to get it completed. Manufacturer seemed to delay sending parts because they can - no good reason provided. First Power Inverter Module (PIM) was replaced, but that did not resolve the issue. Then dealer rebuilt entire transmission. Dealer lead tech stated that a roller bearing near the bottom of the trans appeared to have start failing, which then causes a short and or some kind of damage with the electrical "phasers". Multiple conversations with lead technician and Chrysler cares indicate clearly that Chrysler is NOT investigating the issue deeply (they did not want any of the failed components, nor did they ask for details from dealer - are they even trying to resolve root cause.... this has been occurring since the earliest models). Chrysler should have a financial incentive to fix to remediate warranty repairs. Why can't chat GPT find literally anything on the web about the root cause, why is it nothing other than reports of the issue can be found??? Nobody has done a root cause analysis. Is Chrysler paying to minimize bad press??? If Chrysler replaced entire trans with rebuilt one at 50k and now it failed again at 80k - when can I expect it to fail a third time?

I bought a 2022 Pacifica Hybrid in October 2022. About 2 months ago(Feb 2025), while I was driving on the [XXX] highways, my car suddenly showed "Stop Safely Vehicle Will Shut Off Soon" and a turtle symbol. At this time, I was driving 70 MPH and the car started to slowly stop. Then, I tried to drive into a nearby Starbucks to check it out. I turned off the car. Everything was OK such as oil, coolant, a/c, windshield. Then I restarted the car and the "Stop Safely Vehicle Will Shut Off Soon" and the turtle symbol were gone. I thought it was okay, so I continued driving. 5 days ago (XXX), I had a trip to San Antonio. When I was driving close to Austin. My car showed "Stop Safely Vehicle Will Shut Off Soon" and the turtle symbol again. At this time, I stopped on [XXX]. I feel very dangerous for me, my wife and my 2 children. I feel very scared and confused when I am driving on [XXX] and the car stops like that. I feel like our lives are in danger while driving. Then "Stop Safely Vehicle Will Shut Off Soon" and the turtle symbol appear more frequently. My car has appeared "Stop Safely Vehicle Will Shut Off Soon" and the turtle symbol 6 times in 3 days. Yesterday was [XXX]. When I parked in my driveway, "Stop Safely Vehicle Will Shut Off Soon" and the turtle symbol also appeared. Every day, I must take my 2 children to school in my 2022 Pacifica Hybrid. Now, I feel very scared when driving. I do not know when "Stop Safely Vehicle Will Shut Off Soon" and the turtle symbol will appear again and will cause an accident for my family. We sincerely hope that you will consider and request Chrysler to help us check and fix this as soon as possible. Thank you very much. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Van engine suddenly turned off while I was driving on a local highway on April 3, 2023. Six people were in the car. I was able to stop at a turning lane before an intersection, turned off the engine and after re-starting it worked again. I brought the car to the dealership and was told that there is a 03A recall that will fix the problem. It took 3 week to get an appointment to perform the recall fix. I was told not to drive the car during that time. - On April 20th, I brought the car to dealership for the recall fix. It took only 3 hours and I got my car back. - On April 22nd, I took my family to Torrance area. On the way home, while driving on the HOV lane of I-405 North, my van suddenly slowed down from 70mph - 40mph and continued to cruise at around 40mph. Even when I hit the accelerator, it wouldn't go pass 40mph. Engine light turned ON and a message popped up saying 'Vehicle will shut off soon, stop safely'. But I couldn't stop safely on a super-heavy-traffic freeway where everyone drove 70+mph. So I parked on the narrow shoulder on HOV lane, with cars zooming by. I turned off the engine, re-started it but the condition stayed the same. I turned it off again, this time waited 5 min before starting the engine and it finally turned back to normal. I am too scared to drive my newly bought van now. It is a family van, so my whole family always ride in the van with me. We are in Los Angeles traffic where people drive very fast. When the van shuts off in the middle of the fast moving freeway, it is an accident waiting to happen. It has happened twice in 3 weeks. It happened even after I brought the van in for the recall fix. - Chrysler Pacifica 03A recall fix is not fixing the problem. Please, help us. Pacifica Hybrid owners' lives are at risk every time they drive their vans. They also put other drivers at risk.

My wife was driving our 2022 Chrylser Pacifica when it died in the middle of an intersection in downtown Austin. She was in the turning lane waiting for the light to change when the auto stop/start feature activated. As the light turned green and she went to proceed, the car started up and then cut back off while simultaneously placing itself in park and all of the lights on the dash began blinking and messages stating "service shifter", "service parking brake", "service brakes" etc started popping up on the dash. She tried to restart the car and nothing happened and the emergency flashers would only work intermittently before shutting off and randomly coming back on for a few seconds minutes later. Eventually a police officer pulled up behind her to block traffic while she and they tried to get the car started. When I arrived, I was able to jump the car and get it out of the road and to a nearby parts store to check the batteries. Oreillys and Advanced Auto confirmed that the alternator, batteries and starter were good based on their diagnostic scanners. She was able to drive it to San Antonio and back the next day with no issues, but that night, when we went to dinner and stopped for gas, it did it again while in the fuel line although I was able to restart the car this time but now displays "Stop/Start Unavailable, Service Stop/Start". After the second event, went back to Oreillys and had it scanned, there were no primary diagnostic trouble codes, but 8 stored additional ABS trouble codes relating to low voltage, and electronic failures across multiple systems. This all came after having the oil changed and a safety inspection performed on 23 July in which everything passed, but they recommended a coolant and brake fluid flush. Concerned about this happening in congestion on a highway or somewhere with limited options for recovery.

Vehicle: 2022 Chrysler Pacifica Hybrid. Approximately 25,300 miles On Saturday 9/12/26 while driving at highway speeds the following message displayed "Stop Safely, Vehicle Will Shut Off Soon". When the message displayed the check engine light illuminated as well as the limp mode light. In limp mode the vehicle reduced speed rapidly and would not accelerate above 20 MPH. This happened at highway speeds on a multilane highway. We were able to get to the shoulder, but it was very dangerous changing lanes in limp mode. Turning the vehicle on and off several times cleared errors except the check engine light. We were able to get off the highway and get home without the message or limp mode triggering again. The check engine light stayed illuminated for 24 hours and went off when I refueled the vehicle the next day. For the next week I drove at local speeds with no issues. On Saturday 9/19/26 the vehicle would not start. This is a plugin hybrid and was fully charged. The electric motor would not start, and the check engine light illuminated again. I turned the vehicle off/on 3 times to get it to start. I did my errand and returned home. When I returned home, I turned the vehicle off then on again and the check engine light cleared. On Tuesday 9/21/26 I dropped the vehicle off for service, getting there without issue. The dealership stated the transmission will need to be rebuilt. Problem code is P0A43-00. This is the SECOND transmission failure since ownership. I've had the vehicle serviced only at the dealer where purchased. The dealership confirmed the FIRST incident with the same problem code was diagnosed on 1/30/24. The transmission was replaced at this time. The van had 12,134 miles. The 2024 incident also was triggered at highway speeds. If my memory is correct, I believe I reported the first incident to the nthsb at the time.

The vehicle’s electrical or engine system appears to have failed, causing a sudden loss of power while driving. The exact component has not been identified by the dealership or Chrysler, but it may be related to the recall affecting the vehicle’s powertrain control or electrical system. The vehicle is currently at the dealership and available for inspection upon request. The issue has created a serious safety risk. The vehicle has repeatedly lost power and shut off while driving on the highway, including one incident where I was unable to fully pull off the road before it stalled in active traffic. My children were in the vehicle at the time, placing us in immediate danger of being struck by oncoming vehicles. Because the vehicle can stop without warning, it is unsafe to drive and puts both my family and others on the road at risk. The dealership has confirmed the issue and advised that parts are on backorder for at least 10 weeks. They also stated that even once the parts arrive, they are uncertain how to complete the repair, indicating that Chrysler has not yet provided an effective fix. The vehicle has been inspected by the authorized Chrysler dealership multiple times, and the issue has been reported to Chrysler. It has not been inspected by police or insurance representatives. A warning message reading “Pull over as the vehicle will stop” appears on the dashboard prior to each failure event. The first occurrence was on June 10, 2025, while driving on the highway to my daughter’s graduation. Since then, the same warning has appeared multiple times before the vehicle shuts off completely. It has been 6 weeks at this point and I have no vehicle. Chrysler has offered rental reimbursement of $60 a day but there is no vehicle that is a 7 passenger like my van that is of this cost. At this time they do not have a timeframe of when the vehicle will be fixed and denied a buyback or replacement.

The vehicle experienced a failure of the hybrid battery thermal management system. A diagnostic trouble code (P0E15 – Hybrid/EV Battery Pack Coolant Heater “A” Control Performance) was set and the check engine light illuminated. This component is responsible for regulating high-voltage battery temperature and is part of the hybrid cooling/heating system required for safe operation and emissions readiness. The failure occurred at approximately 100,700 miles on a 2022 Chrysler Pacifica Hybrid. The battery coolant heater is a sealed, high-voltage electronic component with no maintenance or wear interval and is not a consumable part. Loss of proper battery temperature control can affect hybrid system operation, charging, regenerative braking, and power availability, and can potentially result in reduced power or limp-mode operation as the vehicle attempts to protect the high-voltage battery and inverter. The problem was confirmed by a Chrysler dealership and an Area Service Manager using factory diagnostic equipment. The fault code is stored and permanent. The vehicle was inspected by the dealer, and the component was diagnosed as failed and requiring replacement. No accident, misuse, or maintenance neglect was involved. The manufacturer declined warranty or goodwill coverage based on internal policy, despite the failure occurring immediately beyond the hybrid warranty mileage threshold and involving a non-wear, safety-critical hybrid thermal management component. The repair estimate is approximately $1,900 out of pocket. The warning indicator (check engine light) first appeared at the time of failure. The component remains available for inspection and replacement by the dealer. Also the dealership did not provide is with a written justification for the denial and corporate (Stellantis) stated that they were not able to provide justification either other than what the automated prompt was giving them (that the part was not covered under goodwill)

1. Most emergency lights come on while the vehicle's brake engages automatically. The brake then pumps up and down on its own if any pressure is applied. Shortly after, the vehicle goes into "limp mode". The vehicle is currently at a Chrysler Dealership service department and available for inspection. 2. This has occurred 8 times since the vehicle was purchased in October 2024. All but one time, it has happened while driving. Once it happened while on a major highway. I had to quickly veer into a turn lane so our vehicle was not rearended by another car. Another time, I was driving my children to school and it happened about 10 seconds before crossing the worst intersection in our city. That could have resulted in a major crash based on the history of that intersection. A third time, I was traveling at about 40 miles an hour when warnings came on and the brake started to engage. Luckily, I had just gotten off a major highway and I was able to get to the side of the road. 3. The problem has been confirmed by a dealer, since it happened while I was in their service parking lot. However, they have been unable to recreate, find the source of, or fix the issue after 7 times of servicing it. 4. I am unsure whether the manufacturer has sent anyone outside of the dealer's service department to inspect the vehicle. We have been in contact with the manufacturer directly since December 26, 2025 in relation to this issue. Our extended warranty company may have had an inspector out on the first visit to the dealership for the issue, but no one since that I am aware of. 5. Emergency messages have included: Service Electronic Stability Control, Service Charging System, Service Hybrid Electronic Vehicle System, Auto Emergency Braking Unavailable Service Required. Multiple emergency lights come on including: Check Engine, Electronic Throttle Control, Electronic Stability Control Active, Service Forward Collision Warning. The first incident was January 22, 2025.

Vehicle suffered sudden loss of motive power due to Diagnostic Trouble Code P0A43 (Drive Motor A Position Sensor Circuit Intermittent). The failure is caused by thermal and chemical degradation of the internal transmission wiring harness, resulting in an internal electrical short submerged in transmission fluid. The vehicle is able to be powered on again and driving can be continued however certain speeds trigger the issue. The check engine light appears and remains for a short period. The vehicle was purchased through CarMax of Naperville, IL [XXX]. The vehicle began to experience the defined issue the last week of May 2026. The vehicle was brought to CarMax [XXX]. CarMax transferred the repair of the vehicle to Castle Chrysler of Naperville/Stellantis IL, and they conducted the initial repair. Stellantis attempted to mask this hardware failure via software recalibrations under NHTSA Recall 03A (23V-010) rather than replacing physical parts. The vehicle was returned and appeared to be repaired. [XXX] the same issue occurred while on a cross country road trip. The vehicle was able to be driven but under specific speed conditions as not to activate the transmission failure. [XXX] the vehicle was brought to an independent technician at Stephens Automotive in Palatine, IL and they were able to verify the issue and documented it. The vehicle was then brought to Castle Chrysler on [XXX], and the vehicle has been there since. Stellantis later acknowledged the true physical failure via Warranty Extension XE1 and TSB 21-014-26, requiring Electric Rebuild Kit #68729719AB. The vehicle has been continuously grounded at Castle Chrysler since [XXX] (30 cumulative days) because Part #68729719AB is on indefinite backorder. Stellantis's failure to supply hardware repairs leaves the vehicle inoperable and creates a severe safety hazard on public roads. Stellantis Case #[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting an ongoing, catastrophic safety defect and corporate suppression regarding Chrysler Recall 03A (NHTSA Campaign 23V010) on my 2022 Chrysler Pacifica Hybrid. The official recall remedy has repeatedly failed to prevent total electrical system depletion and unexpected motive power shutdown in the field, leaving my family in extreme danger. On March 3, 2023, at 6,000 miles, the vehicle suffered a complete, un-warned motive power shutdown while I was driving my two young children on a rural highway. The vehicle stalled dead on an incline in the middle of a lane. The brakes failed to engage automatically, so I couldn’t evacuate my children because I had to keep my foot on the brake. Cars had to swerve around our vehicle at 55 MPH, as it was on a blind corner. My children were deeply traumatized; my autistic child was completely inconsolable and now suffers from an ongoing, severe psychological fear surrounding this vehicle stopping unexpectedly. We were only saved from a crash because a passerby stopped to help after about 15 minutes. The dealership subsequently applied the Recall 03A software update and replaced the 12V battery. This recall remedy has utterly failed. The replacement 12V battery died again in May 2025 and died a third time in June 2026, proving a chronic electrical defect exists. The dealership refused to perform parasitic draw testing, refused diagnostics, and simply charged the battery, stating 'it's fine.' Chrysler corporate support subjected me to a cycle of unresponsive case managers. One manager promised a buyback review within 3 days, but instead, a subsequent manager closed my file. Corporate explicitly refused to escalate the vehicle to their STAR technical team and flatly refused to provide copies of my warranty and service records. I explained to both corporate and the dealership that I don’t feel safe driving this car without further diagnostics but corporate refused to authorize, stating they stood by the dealer.

In May 2025 shortly after purchasing this vehicle I had complete Brake failure while driving down the road. I was driving approximately 65 mph when the forward collision warning, ABS warning, Brake Warning, Auto Emergency Brake warning lights came on and when I pushed on the brake pedal it was hard as a rock and wouldn't stop the vehicle. It was returned to the purchasing dealership, and they replaced the Brake Booster. On November 27th of 2025 I was driving down the road and the exact same problem occurred with a complete loss of brake function. It went to the local Chrysler Dealership; they replaced the Master Cylinder. I picked it up 12/10 drove it 5 miles home and parked it. I got in the vehicle the next morning to go to work and on my way to work all the same dash lights came on and I had a complete loss of Brake function. It was towed back to the dealership again; this time they replaced the ABS module. I picked it up on 12/30 drove 5 miles home, parked it, tried to leave 3 hours later and couldn't push the brake pedal far enough to get the van started. When I did finally get it started all the same dash lights were on and the brakes were not functional. It was towed back to the dealership again and this time they replaced the wiring Harness. I picked it up 1/16. Drove it minimally over the weekend, on 1/19 the front-end collision warning lights came on and the check engine light came on while driving 70 mph. The brakes didn't lose function this time, however. The following day I was sitting in line at an elementary school waiting to pick up my daughter when all the same dash lights came on again and I had a complete loss of brakes, it was towed back to the dealership, where it still is. There was contact made with Chrysler engineering during the 2nd repair. The dealership has been able to recreate the problem more than once since they have had it. This put myself and my children a significant risk of injury, and other cars if there was an accident.

7/19/23 - Dash warning to pull over because car was going to turn off (from recall software update). (Image attached) Unclear how long I had and upcoming road was more dangerous, so I pulled over in an area with highway speed traffic and only half a shoulder. Car did not reset on first attempt to restart and stuck in "turtle mode" (<10 mph). When I called the dealership, they originally offered me the roadside assistance number, then talked me through reset over phone when I pushed back that I was not in a safe spot with cars flying past me. I was able to drive <10 minutes to dealer after car reset. They were able to get codes and confirm car is undrivable and I need a new transmission. As of 7/28 they still have my car with no update on when part will be shipped. Prior warning: On 7/11, dash showed "put in P to park" alternating with "press brake and push button to start" while driving down the road (note D for drive in lower right on attached images, also photo of car still on/in run). This started at the same time the car bucked and the check engine light came on solid. (Another image shows the red battery warning light in upper left that came on when car was put in park as other messages continued to alternate.) I pulled over and turned off car. While waiting and thinking about what to do next, the car restarted on its own. (It is possible I pressed button 2x to turn off as I recall it didn't react. But restart was a full minute later!) Restarted. Dealership seemed unconcerned, despite the known issue with Pacifica hybrids. Same issue occurred 7/12. On 7/13 the radio rebooted while driving down the road with no warning. (Radio issues have been ongoing and may be related to overall electrical issues?). On morning of 7/19 when final issue occurred, the radio didn't work at first. On 7/14, I pushed dealership to get software recall update that day as it did not feel safe to drive with the ongoing issues. Recall software update was in place before 7/19 incident.

My 2022 Chrysler Pacifica Hybrid has developed a dangerous rear brake system malfunction. During a dealer inspection on 4/27/26, the certified technician confirmed that the rear brake pads are only contacting approximately 50% of the rotor surface, leaving the remaining half completely unused and heavily corroded. This is not normal corrosion or wear. It is a mechanical failure in which the pads are not engaging the rotor correctly. The technician also stated that the pads were sticking in the caliper slides, which prevented full engagement. This is a functional defect in the brake hardware, not environmental corrosion. Corrosion does not selectively prevent half of a brake pad from engaging the rotor unless the caliper mechanism is not operating properly. This defect results in: Reduced rear braking force Increased stopping distance Excessive load on the front brakes Potential loss of stability during emergency braking Possible degradation of the parking brake The vehicle was serviced on 9/23/25 (tire rotation + NYS inspection) and 12/10/24 (four new tires + NYS inspection). No rear brake issues were identified at either visit. If this were normal corrosion, it would have been visible during those inspections. The sudden onset of severe partial engagement by 4/27/26 indicates a latent mechanical defect, not gradual wear. Chrysler/Stellantis has refused to classify this as a defect and instead labels it “corrosion,” despite the technician’s findings of pad binding in the slides and improper brake engagement. The manufacturer’s internal system blocks any warranty or engineering review because it incorrectly categorizes the failure as routine maintenance. This is a premature and unsafe brake system failure at only 33,000 miles. The braking system is not operating as designed, and the defect could lead to reduced braking performance or loss of control. I am requesting NHTSA’s review of this issue as a potential safety defect affecting the rear brake system

When driving on the interstate highway with about 70 mph a warning message “Service hybrid electric vehicle system” appeared. The high voltage battery charging level was less than 1%. About 30 minutes later, after exiting the highway, another warning message was displayed: “Stop Safely Vehicle will shut off soon”. After about 30s later the motive power was stopped and the car continued rolling. There was no propulsion power anymore, and I was only able to roll into the entrance of a parking lot. Luckily it was a relatively safe location where the vehicle came to a stop. I was alone in the car and was not in direct danger. The vehicle could not be restarted. I called a towing service, and the car was transported to a Chrysler dealership. The fault codes were read out. Chrysler Star recommended to replace a 350 A fuse. The dealership service team drove the car for more than 70 miles without being able to reproduce the fault after this repair. One day after collecting the car from the dealership I drove about 300 miles on the highway. After about 250 miles the warning message “Service hybrid electric vehicle system“ appeared. The high voltage battery charging level was less than 1%. When driving on the highway with about 55 mph, about 150 miles after the warning message appeared, the motive power stopped inadvertently without any warning. I felt a short impulse on the gas pedal, then while rolling at below 50 mph the message “Switch P to start engine“ was displayed. I managed to roll out from the 3rd lane from the right to the emergency stopping lane. It was a dangerous maneuver and I feared for the safety of my five family members traveling with me in the car as the oncoming traffic behind my car didn’t slow down even after switching on the hazard lights. The vehicle could not be restarted and I had to call a towing service to transport the vehicle to the nearest Chrysler dealership. Now I am waiting for the service team to start reading out the failure codes.

Vehicle repeatedly entered limp mode / lost power at highway speed a few days after the dealer performing the remedy for NHTSA Recall 23V- 010 (FCA Recall 03A, transmission internal wiring connector short). The recall remedy did not correct the defect. Prior to the recall work, the van entered limp mode on 2 other occasions. Timeline: On 7/10/26, Park Chrysler Jeep in Burnsville, MN performed the open recall remedy (Recall 03A / NHTSA 23V-010) on our vehicle. We informed the dealer we were departing on a multi-week interstate family road trip, and the dealer released the vehicle as repaired. On [XXX], about 40 minutes into our trip, the vehicle entered limp mode with a severe loss of motive power while driving at highway speed on [XXX] between Northfield, MN and [XXX]. We were able to reach the shoulder safely. After multiple restart attempts, the vehicle resumed operation. On [XXX], the vehicle entered limp mode 2 additional times under the same conditions on [XXX] in IL, and on [XXX] in IN, again at highway speed and with heavy traffic present. In one case there was barely enough shoulder to pull over safely. Each event created a sudden, significant speed differential with surrounding traffic. On 7/16/26 the vehicle was taken to Bob Chandler Chrysler Dodge Jeep Ram in Columbus, OH. The dealer's diagnosis is that the transmission must be replaced. The repair order ID is [XXX]. The vehicle is at that dealership awaiting parts. Safety concern: The vehicle lost motive power at highway speeds 3 times in two days after the recall remedy was performed and the vehicle was returned to us as repaired. Occupants at the time included 2 adults and 3 children. No crash, injury, or fire occurred, but each event presented a serious collision risk from sudden deceleration in traffic. This experience is consistent with the concern in NHTSA's reopened investigation that the software-only recall remedy does not address the underlying hardware defect. INFORMATION REDACTED PURSUANT TO THE FR