Kia Telluride 2020

Vehicle experienced catastrophic engine failure while traveling approximately 70 mph on a highway. I heard a loud popping noise and immediately lost power. The vehicle would no longer accelerate normally and I was forced to pull over. White smoke was visible from the engine compartment, and a large amount of engine oil leaked from the vehicle. This failure created a safety risk because it occurred at highway speed, resulting in sudden loss of power while traveling with surrounding traffic. The vehicle required towing and could not be driven from the scene. Prior to the failure, the vehicle had exhibited symptoms beginning around May 11, 2026. A check engine light illuminated and an independent mechanic diagnosed a cylinder 3 misfire and replaced the ignition coil. Following that repair, the check engine light returned. Additional symptoms included stalling at idle, knocking noises from the engine, and intermittent oil pressure warning lights. The vehicle was subsequently inspected by an independent mechanic who diagnosed a thrown connecting rod with damage to the engine block, including a hole in the engine near the transmission area. The mechanic advised that the engine requires replacement. The damaged engine is currently available for inspection. The vehicle has not been inspected by the manufacturer. No injuries or crash occurred, but the sudden engine failure and loss of power at highway speed created a significant safety concern.

I am writing to formally file a complaint regarding a known defect in my 2020 Kia Telluride, which is experiencing severe and excessive oil consumption that poses a potential safety risk and financial burden. Vehicle Information: •Make/Model: 2020 Kia Telluride Since ownership, I have experienced repeated and worsening oil loss between routine oil changes — with no visible leaks or warning lights in most cases. The rate of consumption is approaching or exceeding 1 quart per 1,000 miles, which Kia itself defines as “excessive” under Technical Service Bulletin ENG222 (Rev 5). This condition not only creates a risk of engine failure while driving, but it also puts owners like myself at risk of uncovered repair bills in excess of $12,000. I have already contacted my dealership, Kia Corporate, and Fidelity Warranty Services, and was told coverage is uncertain — despite this being a well-documented issue affecting a wide range of Kia engines. I believe this is a safety defect that warrants further investigation due to: •Sudden engine failure or stalling from low oil levels •Lack of adequate early warning indicators •Unreasonable financial exposure to consumers for a manufacturer-related defect •A potential pattern of complaints across similar models/engines As a responsible vehicle owner, I respectfully urge the NHTSA to investigate this matter further and ensure Kia is held accountable for this widespread and dangerous issue. Thank you for your time and consideration.

The check engine and oil pressure light will start to flash when starting to brake. While this is happening the car starts to shake, stall, and you struggle to accelerate. This has happened multiple times and the last time was in the middle of an intersection. KIA dealership did not fix the issue the two times I took it to the shop. The third time in they did some test and said it was an oil consumption issue and the piston rings in the SUV have failed and the car needed a new engine. This car is a 2020 Telluride with 78,759 miles on it. This issued started well before the 78,759 miles. Oil consumption has been a major issue with other KIA models and they have not seemed to fix this issue with the telluride. I believe they have replaced engines at an extremely high rate and now they are denying engine replacement under their warranty and stating piston ring damage is not covered under the warranty due to high oil consumption. You guys have issued a recall on 2021-2023 Seltos and Soul models for piston ring failure and now they do not want to start replacing tellurides. There is a Facebook page out there labeled KIA telluride issues with oil consumption being a big issue in the comments. KIA stating they will not cover the engine replacement is not only wrong is it a safety issue. I truly believe they know this is a serious issue and have not done anything to correct it. This vehicle is still under warranty and I am still in contact with the dealership to fix this issue.

The power sunroof and its sliding track/rail assembly failed. While operating the sunroof using its normal electric open/close function during highway driving, the sunroof glass/panel traveled to full open and the track mechanism broke at that point, preventing normal closure. The vehicle and damaged sunroof/track assembly are available for inspection upon request. The failure occurred while the vehicle was in motion on the road, creating a distraction and an unexpected open aperture in the roof at highway speed. An uncontrolled/stuck-open sunroof exposes the cabin to wind, debris, weather, and noise, and could distract the driver attempting to address the malfunction while driving. There is also risk of glass or track hardware detaching from the vehicle. A Kia dealership inspected the vehicle and confirmed the track is broken and quoted approximately $5,000+ to replace the sunroof assembly, citing no applicable warranty coverage. No warning lamps or messages appeared prior to the fail I have found other consumer complaints/forum reports describing similar sudden sunroof track failures on this make/model during normal operation, suggesting this may be a widespread component defect rather than an isolated incident or wear item. Despite this, the manufacturer has not issued a recall or extended warranty coverage for this failure mode, leaving owners to pay approximately $5,000 out of pocket for a repair caused by what appears to be a manufacturing or design defect rather than misuse.

Car has been brought to KIA for transmission issues multiple times and the associate tells me to just tighten the gas cap to get the light to go off. The car is not shifting properly and will "jump" or "lunge" forward while driving. I have noticed that the RPM's will jump and bounce around, seemingly down shifting, then shift again, and then down shift again, which causes jerking motion. The reason I initially took the vehicle in was for a "shake" or "wobble" when accelerating up a hill (semi steep incline) or at freeway speeds (55-70MPH). In these instances, the vehicle will have a hard time shifting and temporarily lose momentum causing concerns for me and other drivers on the road. The transmission light will go on and I call KIA to be told to tighten the gas cap. I recently brought it in for the third time and they diagnosed something different. I have mentioned the transmission each time, but they have focused on other items and not the transmission. I have had the shocks replaced, the tires replaced, alignment performed, and the problem still persist. However, the dealership will not look at the transmission and says that it is the other items, but the issue still remains after fixing the other items. The shock failure caused other items to wear out and the dealer should be on the hook for those items. I have brought the vehicle in dating to last year for the transmission issue with no help from the dealership. Please take action so that we don't lose our lives or put others at risk for injury.

Vehicle experienced significant drivability issues including shaking/clinking at speeds over 50 mph, check engine light, and reported two-cylinder misfires. Engine oil level was critically low, not registering on the dipstick, requiring approximately 2 quarts added to continue driving. An independent mechanic inspection found excessive oil in Cylinder 2 and assessed that oil was likely leaking past the piston rings and burning, recommending a bottom-end rebuild or engine replacement. Kia dealership (Sunset Kia) inspection subsequently found a score mark in Cylinder 6 and two external oil leaks (oil pan gasket and oil filter housing). Kia approved goodwill repair of the external leaks only, after which I was instructed to drive approximately 1,000 miles for a follow-up oil consumption test. After that period, the dealership confirmed the engine was still consuming oil beyond the external leaks. Kia Corporate took approximately three weeks to review a goodwill request for engine replacement, ultimately denying it. During this three-week period the vehicle remained at the dealership, and I incurred over a week of out-of-pocket rental car expenses due to no loaner vehicle being available and no transportation assistance offered. The vehicle has fewer than 100,000 miles. I am concerned this reflects an internal engine defect (oil consumption/piston ring or cylinder wall issue) affecting the vehicle’s safe operation, given the drivability symptoms (shaking, misfire, near-zero oil level) that initially prompted this investigation.

While driving on the interstate at 60MPH a very small pebble hit my windshield on the top rhs and put a dime sized hole in the windshield coming to a point on the inside making a complete opening. It is now starting to crack like a spiderweb. Safelite has refused to touch it and the dealership has stated it will take several weeks to get a replacement and the cost is upwards of $750.00+. This is absolutely ridiculous, when you pay this much for a vehicle and you have to return to the dealership to obtain a cheaply made product and pay a not so cheap price for it. This is absolutely highway robbery. The service department recommended I turn this over to my car insurance. After speaking with my insurance provider, I learned my Premium will increase due to having to file a claim. So, basically I'm going to have to pay an enormous amount of money for a cheaply made product or pay an enormous amount of money over who knows how long for a cheaply made product. From looking at the growing amount of complaints, there appears to be a legitimate cause for investigation into the product KIA is putting into their vehicles and selling to consumers. Additionally, should something small come through one of these windshields and injure a person inside of the vehicle or cause an accident, I would presume the affected individual(s) would have a legitimate ground for a potential lawsuit. There are far too many complaints being filed against KIA for this same issue and failure to investigate this many complaints by consumers is reckless.

Vehicle burns oil, current mileage at 169k. User manual indicates 7500-10000 miles between changes, I am original owner. Dealership service set for 5k intervals since purchase and done on time. At 99k noticed noises from engine, light rattling but couldn't replicate and couldn't pinpoint at dealership service. At 112k noticed burning oil and rattling noises when accelerating from stop. Changed to 3k oil change intervals, began using premium fuel. 1quart of oil at 0-1000 miles from oil change (had a consumption test at dealership and confirmed "normal" at 112k), sub sequential mileage burns more than 1quart between 1k intervals, can easily burn through 4-5quarts between 3k oil changes. Oil smells slightly like gasoline closer to oil change time. Outside mechanic confirmed rattling as detonation. Concerns of oil not "burning" but mixing with fuel either through oil vapors getting through PCV valve and diluting fuel octane causing rattling. Knock sensor suppresses from causing engine damage, but still happens. Fuel may be getting into the oil, not sure how, but wouldn't explain detonation. No codes, no other issues. Only check engine light since rattling noticed at 99k was failing O2 bank 2 sensor which was replaced by licensed mechanic with OEM parts. The amount of additional oil maintenance and changes were not disclosed on expected maintenance costs sheet posted on vehicles, nor is it communicated in the users manual. Personal opinion is the additional maintenance between changes is unreasonable, and oil isn't "burning" but leaking into the combustion chamber.

With 40k miles on the car driving on the freeway the coolant hose burst without any warning, it didn’t come off, it was weak and split. This caused head gasket damage and cylinder 3 and 5 to misfire with coolant getting in the cylinders. It was dark and foggy out and the car was over heating due to the failures. I lost power and could only go 25mph on the freeway. Semi trucks were honking flashing their lights, passing me and one slammed on the brakes to avoid hitting me due to how dark it was. Even though I was driving with my hazards on. I pulled over as soon as I could, but had a panic attack during the ordeal planning out the best way to die. Sounds dramatic but with all the smoke coming from the car I thought it could blow or get hit by a semi. Looking at online groups there are issues with the Telluride engines that are creating dangerous situations. It’s a matter of time before this problem causes a serious injury or death. I know others that have made complaints to Kia and NHSTA. When is this problem going to be taken care of?? My car has been at the dealership since Dec 19 2023. I am waiting to here back from Kia if they will cover the engine under warranty. The dealership said they had another Telluride with engine failure in Oct 2023 that Kia did not cover under warranty. The dealership has confirmed all these statements. There was no warning that there were any weak spots in the hose. No leaks or warning lights until it left me stranded on a dark foggy night on the freeway. Since Kiefer Kia in Eugene, OR still has my car I have not received any paperwork yet

My check engine and oil lights have come on more than once around the time of needing an oil change. During that time, the engine bucks, and the RPM revs high and low. The Kia Service Dealer, both times, stated that the light was coming on because the oil was low. The first time they replaced the spark plugs as a precaution, since the check engine light state miss-firing. That didn't fix the problem, because the light came one again right before the next oil change was needed. And this time, the car actually stalled out at a red light. They said the oil was really low the second time. I asked where the oil could be going. They said it wasn't leaking that they could tell, and that Kia says its ok to lose about a quart every 1000 miles. I don't agree with that, especially with a 4 year old car. So I had another family member drive the car while I followed, and sure enough I saw black smoke coming out of the tail pipe. So, the engine is burning the oil. On top of all this, I noticed that the screen (which they just did a software update on) right side compass keeps appearing suddenly and then disappearing, without anyone touching the screen. Then I noticed yesterday, after I parked. The Emergency Brake turned out all by itself, without me pulling the button up. The red light indicator came on also, then turned off and on and off. Lastly, the forward movement button on the driver side button doesn't work, which I thought was supposed to be repaired as part of the last recall. All in all, I am afraid to drive this car because I think the engine or seat is going to catch fire at any moment.

At approximately 94,000 miles, my 2020 Kia Telluride EX experienced a significant internal engine failure. The vehicle was properly maintained in accordance with the manufacturer’s recommended service schedule, including regular oil changes. A professional inspection required engine teardown. During inspection, the piston for Cylinder 6 was removed. The oil control ring was found to be stuck and would not move, with excessive carbon buildup present on the piston rings and piston crown. The cylinder walls and piston side skirts showed excessive scoring. According to the inspection findings, excessive carbon buildup caused the piston oil control rings to become stuck, allowing oil to bypass and resulting in damage to the cylinder walls. The inspector determined that the required repair is full engine replacement. This failure was not caused by misuse, neglect, or lack of maintenance. The vehicle has been inoperable and in the repair shop since approximately August 2025. An internal engine failure of this nature occurring under normal operating conditions raises concerns regarding engine durability and potential manufacturing or design defects that may affect other vehicles with the same engine configuration. Multiple owners of 2020 Kia Telluride vehicles have independently reported similar symptoms of excessive oil consumption, internal engine failures, and the need for major engine repairs or replacements at comparable mileages, some documented in NHTSA complaint records and owner forums. I am submitting this complaint to document a potential engine defect and to support investigation into similar failures.

What component or system failed or malfunctioned, and is it available for inspection upon request? The factory paint on my 2020 white Kia Telluride has failed. The paint is peeling and flaking from the hood and the roof of the vehicle. The vehicle is available for inspection upon request, and I have photographs documenting the paint failure. How was your safety or the safety of others put at risk? The peeling paint exposes the underlying metal to the elements, which may lead to corrosion and deterioration of the vehicle over time. Pieces of peeling paint may also detach while the vehicle is being driven, creating a potential hazard for other motorists. In addition, the loss of the factory paint significantly reduces the value of the vehicle and raises concerns about the quality and durability of the manufacturer's finish. Has the problem been reproduced or confirmed by a dealer or independent service center? At this time, the problem has not been confirmed by a Kia dealer or an independent service center. However, I have found numerous reports from other owners of white Kia Tellurides experiencing similar paint peeling issues, suggesting this may be a widespread manufacturing defect. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? Not at this time. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lights, messages, or other vehicle symptoms before the paint began peeling. The issue developed gradually as the factory paint began separating from the hood and roof under normal use.

Vehicle began having issues around 60,000 miles. Stutters and slips between 2nd and 3rd gear. When on an incline the issue is much more prevalent. On a steep incline, the vehicle is like lurching it is so prevalent and it feels as though the vehicle is going to give up. Around 45 mph, the vehicle begins vibrating; as speeds increase, the shaking (left to right) becomes increasingly violent. At times, it feels as though the vehicle is going to shake off the road. The issues I primarily when accelerating, and when the gas pedal is released, the shaking slows almost to a stop. Tires, balance, and alignment checked multiple times over the course of the issue and tires are changed seasonally. Took to dealership multiple times to be told there was no issue with the vehicle and it was operating properly. Just over 100k miles, back at the dealership and there is suddenly an issue found. Was told at dealership that passenger side front axle inner race is damaged and needs replaced. Took vehicle to local mechanic since dealership had jerked us around so much over the issues, not repairing, keeping car for extended amounts of time without a loaner vehicle, etc. Local mechanic did a lot of research. This is a common complaint of the Telluride and Kia is aware but is not doing anything about it. Mechanics recreated issue immedately said rear driveshaft had movement it shouldn't and replaced. They also serviced the transfer case and transmission. There is a TSB issued on this, but research suggests that it is not resolving the problems and kia dealerships are not acknowledging the issue until out of warranty and TSB doesn't cover the repairs even though it is faulty manufacturing.

Engine oil is disappearing in my 2020 Kia Telluride. This has been occurring for an extended period of time ( Since 2020) Early on, I was not driving frequently and did not immediately recognize the severity of the issue. However, about a year ago, when my work required significantly more driving, I began noticing that a large amount of oil was missing between checks, at times approximately half of the engine’s oil capacity. I initially suspected the plastic oil filter housing, which can crack or leak if it is over torqued during oil changes. To address that potential issue, I purchased an aluminum oil filter housing and had it installed. While that repair resolved one concern, it did not stop the ongoing oil loss. At times, when I check the dipstick, there is little to no oil registering, indicating the engine is operating on residual oil. When I remove the oil filler cap, smoke is visible coming from the opening. There are no signs of external leakage, no oil on the ground, and no oil leaking under the engine. This strongly suggests the engine is consuming oil internally. This is a serious safety concern. If the oil level drops unexpectedly while driving, the engine can suffer sudden damage, lose power, stall, or fail without warning. Because I regularly travel for work between Florida and Georgia, including highway driving, I now carry bottles of oil in the vehicle and feel compelled to monitor and top off oil frequently out of concern that the engine could fail or stall while driving, potentially leading to a crash, injury, or loss of life. Based on my research, I understand I am not the only Kia Telluride owner experiencing this type of abnormal oil consumption or unexplained oil loss.

I have a Kia Telluride 2020 EX AWD automatic. I bought it used about 2.5 years ago. It’s been having some ongoing issues with oil consumption, which from what I have learned is pretty common in this car. Since I learned that I’ve been increasing the frequency of oil changes and topping off oil in between. It burns oil at an absurd rate, and gives no warning when oil is low. On the most recent change, a month ago, the mechanic recommended changing it after 3,000 miles. Yesterday the car completely shut down while driving on the highway, no warning or anything, just a noise, smoke and then the car died in a matter of seconds. I nearly got in an accident trying to drift to the side of the road with no power or anything. No control of the car. Ended up stuck in traffic going 70 mph with a toddler. After it was towed, our mechanic found there was no oil left and we had two holes in the engine casing. He explained it looks like when the oil ran out completely, some part broke off in the engine and shot through the housing. So it’s looking like we need a new engine. We had NOT driven it 3000 miles since the last oil change just a month ago, and we have even topped off the oil since that change, most recently a week ago. This means the car burned through about 9 quarts of oil in 3000 miles. Multiple mechanics have told us this is a known issue with the car, and there is nothing to do to prevent it. When we called the dealership to inquire about getting a new engine, they told us we would need to do an oil consumption test. Obviously this is impossible on a car that does not drive and has two holes in the engine. So we are stuck paying out of pocket. Kia is well aware of this issue and is doing nothing.

Upon braking the vehicle would run rough and the engine would shut off completely. This was first noticed when my wife was turning into our driveway and turning across traffic. She was heading westbound and slowed down to take a left(northbound) into our driveway. Upon braking the engine started to run rough & as she accelerated to turn into the drive, the engine shut off completely. This left her stranded turned perpendicular to oncoming traffic. The oncoming traffic narrowly avoided an accident and left my wife shaken from the incident. I brought it into the dealer where after multiple days of investigating found the vehicle was 4.9l of oil low. There was no indication of low oil in the engine; no indicator light or sounding of low oil, prior to complete engine shut down. The dealership stated when the vehicle shut off, the low oil light would then turn on. This is possible as when it had shut off on me while bringing it to the dealer, there were 4-5 lights that would turn on when the vehicle shut off. The dealership performed an oil change, which it was near to the mileage for needing an oil change anyways. Since this was completed we have not had any issues since. I am working with the dealership currently on why the vehicle is consuming so much oil, but my main concern is there was no warning or indication before the vehicle shut off while in normal driving conditions. I called Kia service and the dealership today and they stated the light should come on when there is less than .5 qrts of oil left in the engine. They believe I did not reach the threshold for the light to come on, but again my concern is the only first indication of low oil should not be my vehicle shutting off in an unsafe condition.

My 2020 Kia Telluride completely stalled on me on my way to work. The vehicle was not smoking and it seemed like it went on accessory mode. I had the vehicle towed to Kia Dealership in Perris to get it checked out and was told by Olivia that no codes were read when doing a diagnostic and that my engine seized. I had purchased an extended warranty through AGWS. AGWS reached out to me to request the vehicle service records which I emailed over as Subject: [XXX] to [XXX] Today March 21, 2024 we receive a call from Olivia stating that my warranty will not cover the cost as they're claiming that we failed to service the car. Our vehicle was services as advised and stated using the appropriate Synthetic oil. I was informed that they would be breaking down my engine to see where it went wrong as there were no codes read. They also stated I had to pay for the engine breakdown $200 per hour and it would most likely take 8 hours (According to Kia). Now, I've gone on many online forum and many people have experienced this problem with their 2020 Kia Tellurides all under 75,000.00 miles. I contacted Kia Corporate as well but that got me nowhere. I don't understand how these vehicles don't have a recall as of yet for these seized engines. I also don't understand how following the oil recommendations for oil changes is suddenly considered "Lack of service". No one is willing to work with me and suddenly it's my fault that I bought a faulty vehicle. Thank [XXX] I was able to putt to the shoulder of the freeway safely as this is my family vehicle where I drive with my [XXX] and [XXX] . Please investigate as it could be a possible recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Purchased vehicle 8/31/2021 - 32k miles 10/18/21 - first mention of oil consumption (opened case with Kia) 2023,2025,2026. 3 more cases filed and DENIED with Kia customer care. Filed BBB claim, filed BBB anutoline claim, also hired lemon lawyer. Kia offered $6k to go away (I declined). *July 18,2026 Kia finally diagnosis and recommends engine replacement. Bore scope was used to discover scoring on cylinders from significant oil consumption. Vehicle is now smoking at take off (112k miles), current open case with Kia customer care again. Requesting buyback or settlement for the 3rd time in 5 years. Still paying $600 a month Safety concern: on a trip out of state vehicle dash lit up every icon and went dead in the middle of a packed 4 lane highway , started with power steering, no lights, no horn , couldn't roll window down.(video avail) Vehicle towed to dealership. Had replaced battery 2 times already. This has happened twice and my family was in the vehicle once on the large highway, very scary no one knew we were broke down bc we had no way to show it. People blowing and zooming by mad. Low oil light doesn't exist on this vehicle, I've been bone dry with no indication EVER. I now ride around with a 5 quart jug of oil and funnel in the back of my car since 72,000 miles. This should be illegal. Rear suspension: 4 times the rear suspension has been replaced (7 times in the shop to be fixed one time over 30 days) and has never been fixed , now making the same knocking noise it's always made. The car is a lemon and Kia knows it and will not stand behind their product. I DO NOT FEEL SAFE IN THIS VEHICLE, kia has been notified numerous times in every avenue and every way I could communicate, they say "we will call you with an update when we have one" that call NEVER happens.

I am filing this complaint regarding my 2020 Kia Telluride because of excessive oil consumption that Kia has refused to address. My vehicle currently has approximately 138,000 miles and consumes about one quart of engine oil every 500 miles. This level of oil consumption is excessive and creates an ongoing risk of engine damage if the oil level is not constantly monitored and replenished. After researching this issue, I discovered that many Kia owners have reported similar excessive oil consumption problems. Despite the large number of complaints, Kia has not issued a recall or provided assistance for owners whose vehicles experience this problem after the factory warranty expires. I sought assistance from my local Kia dealership. At one point, the service manager attempted to advocate for me and other customers by bringing these concerns to Kia corporate. I later learned that he was no longer employed there. They have completed oil consumption tests and agreed my car is consuming a significant amount of oil. They conducted a “band aid” fix that did not help. The last appointment when we brought it in, all they did was check oil levels again. Since then, my concerns have largely been ignored, and I have been offered no meaningful assistance. While I understand my vehicle is outside the warranty period, a vehicle should not consume one quart of oil every 500 miles under normal operation. This appears to be a widespread issue rather than normal wear and tear. I respectfully request that this complaint be investigated and added to the record of similar complaints involving Kia vehicles. I also ask that Kia be encouraged to provide assistance to affected owners whose vehicles suffer from excessive oil consumption caused by what appears to be a common defect. Thank you for your time and consideration.

My 2020 KIA Telluride has had electrical problems since 3 months after purchasing it in June of 2019. It started out small with my backup camera glitching/not being visible, the interior lights flickering, and my heat not working properly. Then, it quickly escalated to multiple emergency lights engaging in my dashboard while driving or stopped. I called the dealership and was told if the codes aren't active they can't service the vehicle, so when it happened again I brought it to them directly. At this time my vehicle wouldn't go in reverse and the steering wheel locked. The diagnostic report stated the car lost communication with fuel pump control module, instrument panel cluster (lpc), control module (ccan),and HVAC control module. This happened on two occasions compromising my family's safety. On the 3RD occasion, the following happened: the steering wheel locked, shifter wouldn't work, no lights next to shift, wouldn't go in reverse, no backup camera. On the 4TH occasion, the following occurred: warning lights/emergency lights on dash, steering locked, no lights near shifter, steering tight, RPM indicator went to zero, speed went to zero, warning lights switched on an off to different ones. The dealer replaced the floor harness, dash harness, and engine harness. Even after these "fixes" it continued. On the 5TH occasion, the emergency lights came on and my vehicle shut off while driving and I lost my brakes! The following occurred before the shut down: forward collision warning light, emergency light, RPM indicator up and down, ABS warning light, degree/temp light flickering on and off, plus a few more warning lights. This time my car had to be towed. KIA will not take the car back and denied my claim after supplying over 70 pages of documentation. My car has been in the shop for a total of 84 days since October 19, 2020.

All of my oil changes have been done religiously at the same Kia dealer where I bought my 2020 Telluride but ever since my 1/14/23 oil change, I have experienced oil leaking from my car on and off. Was told by the dealer that the issue was faulty oem oil filters and that the o-rings weren't sitting properly. I have had a total of 8 oil changes between 1/14/23 & 10/9/23. I explained on 3/25/23, during one of my return trips to the dealer, that I didn't want my car back until they could guarantee it wasn't leaking. They had it up on the lift, ran it for a while, gave it back to me, no leaks finally! My car didn't leak between 3/25/23 & 6/10/23 when I had my next routine dealer oil change done. I also didn't experience any leaks between 6/10/23 & 9/5/23 when I had another routine oil change. However, shortly after the 9/5/23 oil change, we discovered the car was leaking oil again. Brought it back to the dealer on 9/25/23 where they said it was another bad filter, changed it and sent me on my way. The following week, I noticed oil leaking, yet again, so I brought the car back to the dealer where they then diagnosed it as a cracked oil filter housing. I am out of warranty so naturally they expect me to pay out of pocket. Either way. I don't see how this is a consumer issue considering I had 8 oil changes in 10 months when I should have only had 2 or 3. So if the oil filter housing is now indeed cracked, the additional wear & tear is not a result of normal wear & tear (consumer issue) but of excessive oil changes done by the dealer due to faulty oil filters. Or maybe it's been a crack in the plastic oil filter housing all along but then why didn't it leak between 3/25/23 & 9/5/23? Either way, the problem shouldn't fall back on the consumer. The internet is full of Kia owners experiencing oil leaks after oil changes and it needs to be addressed.

The torque converter is malfunctioning to where I have been unable to use my vehicle for almost 2 months. It is available for inspection, but is currently at a repair shop pending inspection to get an estimate on costs to fix the issue (if it is something that can be fixed). My safety along with my family's safety were put at risk due to the inability for the vehicle to pick up speed while driving on major highways [XXX]. During this time the check engine light came on for the 1st time, the vehicle would not properly pick up speed, continuously makes a whining noise when vehicle is on whether it's being driven or not and it shakes at various speeds. A diagnostic was completed and the code listed was for the torque converter. Since that time (1st week of February), I have not been able to drive the vehicle. This is the only vehicle in my household. I am still having to make payments on it and cannot use it. KIA has had a recall in the past issued in June 2020 for a specific timeframe of vehicles produced between May 18, 2020 - May 20, 2020 for the "Automatic transmission/Torque Converter Assembly Replacement". With this recall, KIA only listed 19 VIN's to associate this major issue with. The recall also stated to complete this action prior to the sale of the vehicle to prevent customer complaints. My car was manufactured in June 2019 and I purchased it mid year 2020. If KIA has sold thousands of Tellurides since that time, how can only 19 be affected? I have attached a copy of the previous recall. Once I receive an estimate, I can also forward it. I also have copies of every/all maintenance completed since getting this vehicle to show everything has been completed on time & by a KIA dealership in my area (it doesn't let me upload this file). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On September 24th, 2026, while traveling with my family in my 2020, KIA, Telluride, the vehicle began experiencing an unusual engine vibration approximately 200 miles into our trip. About five miles later, I exited the freeway and stopped to inspect it. Once stopped, the engine began knocking loudly. I checked the engine oil and coolant levels; both appeared normal, and the temperature gauge was at its usual reading. After waiting about five minutes, I restarted the vehicle, but the knocking became worse with each start. I stopped running the engine and had the vehicle towed to a Kia service center. The vehicle had approximately 99,350 miles. The shop has described the engine problem as a “catastrophic failure.” The cause and specific failed components are cannot be identified in this kind of failure. This sudden failure during freeway travel with my family created a serious safety concern and I am sure this needs to notified so that it doesn't happen to anyone who own's the same car. There are particles of metal shavings found in Oil filter which concludes engine failure with no explanation. Only option I am given is get the engine swap which is ~70% of the total cost of the car. Kia support just says since the car is out of warranty they cannot do anything about it. This is a serious durability issue. I totally understand that the car warranty was reduced for the 2nd owner, but first user could also get this problem on the freeway and can be dangerous for everyone driving in the car as i am still under 100,000miles. I am trying to spread awareness, Kia already acknowledges that consuming 1qtz of oil every 1000 miles is normal, which means the engine has a issue that Hyundai/Kia needs to fix before more family starts facing this with even worse situation than ours. Please look into this so that they can acknowledge fix the problem and opens a recall for fixing it.

I reported a suspected defect on my vehicle 1/26/22. With 44,000 miles, the car began stalling and having difficulty accelerating from a stop at busy intersections. Germain Kia Dealership on Georgesville Rd in Columbus, OH where I purchased the vehicle new has refused to adequately investigate this issue, and has refused to make any repair for the open recall on this vehicle involving taillights and the trailer hitch. Dealership stated it would only make repairs if I bought a $15,000 new engine from them, and they stated that Kia would not honor my manufacturer's warranty, nor would Kia honor my extended warranty sold to me for $2,000 at time of purchase. Dealership was acting as an agent of Kia when taking this action. I filed a complaint to Kia headquarters, but this scheme to defraud was endorsed by Kia through a lack of action. I was assigned case number 14636950 by Kia, but the automaker took no action. My recall item was not repaired, and the suspected defect that involves stalling on my two-year old engine was not addressed at all. My records show 5 oil changes since buying this car, but Kia's Columbus, OH dealership says only oil changes done by their own dealership count. None of my oil changes done by other ASE certified repair facilities will be recognized. Dealership says Kia will not honor any warranty due to lack of maintenance. I can prove vehicle was maintained properly. When I escalated this matter to the dealership sales manager, service manager, and general manager, they took no action. I was denied repair on the recall item, as dealership and Kia tried to trick me into buying a new engine, they breached my warranty and my extended warranty, and they did not investigate the new potential defect involving power train. Please do not allow Kia and its dealers to defraud other customers and keep unsafe cars on the road in this fashion.

While operating the vehicle and braking, the dashboard warnings lights began flashing. The brake pedal went to the floor and did not brake the vehicle. No amount of pumping of the brakes helped. At about 3-5 MPH I struck the stopped vehicle in front of me at an intersection. Later that day the same thing happened, and this time I pulled the emergency brake lever and held it. The warning alarm sounded but the brakes never slowed or stopped the vehicle. I drove the vehicle safely to a repair shop and it was then towed to a Kia dealership. Where it is available for inspection. The error codes on the ECM indicate that the right rear ABS Speed Sensor has lost communication. I do not know if the component has been inspected by KIA. When the failure occurs the BCW light goes on, the ABS light goes on, the Master warning light goes on, the Electronic Stability Light goes on, and the AUTO HOLD lights amber. The dealership has reviewed the codes on the ECM which follows: ABS/ESC(+EPB) 2 Codes 1.C121102: Wheel Speed Sensor Rear-RH Invalid/no Signal 2.C121002: Wheel Speed Sensor Rear-RH Range / Performance / Intermittent Integrated Body Control Unit- BCM 1 Code 1.B121200: Front Center Right Sensor Fault Integrated Body Control Unit- SMK 1 Code 1.B121200: Front Center Right Sensor Fault Integrated Body Control Unit- TPMS 1 Code 1.B121200: Front Center Right Sensor Fault PSM (Power Seat Module) 1 Code 1.B163700: System Not Initialized BCW (Blind-Spot Collision Warning) 2 Codes 1.C169381: ESC Signal Error 2.C167581: Signal WHEEL FL or WHEEL FR or WHEEL RL or WHEEL RR not Valid MFC (Multi Function Camera) 1 Code 1.C186286: Invalid Signal of SCC SCC (Smart Cruise Control) 3 Codes 1.C121181: Wheel Speed Sensor Rear-RH Invalid/no Signal 2.C136081: ESP Irreversible Error 3.C174181: ESC-not available VSM (Check ESC) 4WD Control 1 Code 1.P183000: Clutch Torque Tolerance Lower Limit.

I have a 2020 Kia Telluride that I bought brand new from Kia. I have performed regular maintenance on the vehicle and performed the repairs required by any recalls. When my vehicle surpassed 75k miles, the vehicle started having issues with excessive oil consumption. I had my vehicle serviced at 75k miles with the oil changed. When my vehicle was passed 79k miles, the vehicle started stalling, piston misfiring, and engine started vibrating. I took it into the dealer, and they performed diagnostic tests. The determined pistons were working fine but my oil level was very low. This was around 4k miles after my oil change. Kia requires oil changes every 7500 miles. I had the dealer change the oil. Once again, when my vehicle was approaching 4500 miles, the vehicle started to vibrate, piston was not filing properly. I checked my oil level, and it showed very minimal oil on the dip stick. The oil level was well below that was needed for the engine to properly operate. I put closed to 5 quarts of oil to get the engine to the oil level it needed. I am concerned that the excessive oil consumption can lead to the vehicle stalling on the road resulting in collision with other vehicles resulting in bodily injury or harm. According to Kia the oil consumption is fine. How is consuming 5 quarts of oil in 4500 miles fine when the manufacturer states oil changes are required every 7500 miles? The engine itself has a capacity of 6.9 quarts. At the rate my engine is burning oil, I would need over 7.2 quarts of oil to drive 7500 miles. Additionally, having an engine continuously operating with low oil would result in engine damage and thousands of dollars in repairs. The problem I am having in my vehicle is experienced by thousands of Kia Telluride owners. It's the same problem Kia has had in the past with other models. Kia is trying to avoid repairing their defective vehicle and placing the burden on the consumer.

This is a follow-up to Complaint #11666572 regarding my 2020 Kia Telluride (VIN: [XXX] ), with urgent concerns about ongoing safety violations and abusive conduct by Greenway Kia East and Kia America. On June 26, 2025, Kia America reversed its prior refusal and agreed to reimburse Uber, rental, and towing costs—but only after I filed multiple complaints. Earlier, they claimed to have no influence over the dealership, which had refused all reimbursement after I complained about Service Manager Gina. Worse, on June 27, the dealership responded via BBB telling me to contact Gina again—the very person I formally complained about for unprofessional and negligent conduct. This isn’t just mishandling; it is degrading, retaliatory, and dangerous. Key safety/legal concerns: • My vehicle was returned on May 31, 2025, with dangerously low coolant, just days after engine replacement—posing a critical safety risk. • The service manager dismissed my concerns until I insisted, then acted with open disrespect. • Repairs were withheld May 19–28 unless I paid $1,833.77, despite warranty coverage. Only after I came in person on May 28 did they reverse and offer free service. • I was charged $580.97 for a diagnostic test tied to a manufacturer defect that led to engine replacement—still not refunded. • The pattern of neglect, retaliation, and deception from both the dealer and Kia America endangers drivers and violates federal safety standards. This dealer has acted with impunity since May 19, 2025. Their behavior is abusive, unsafe, and incompatible with their licensing. I urge NHTSA to investigate whether Greenway Kia East should retain its dealership license. Their conduct undermines public safety and federal standards. A full follow-up and attachments were sent to NHTSAmedia@dot.gov from [XXX] . Please contact me for documentation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am the original owner of a 2020 Kia Telluride that was purchased new in December 2019 and currently has approximately 98,000 miles. The vehicle has been routinely serviced, including regular maintenance performed through authorized Kia dealerships. Recently, the vehicle developed a serious apparent engine problem. An independent repair facility inspected the engine oil and found it was very low and visible metallic particles/shavings in the oil. The oil also appeared abnormally burned. The repair facility found no evidence of an external oil leak and advised that the vehicle should not be driven because of the condition of the engine oil and presence of metal. I had the vehicle towed to an authorized Kia dealership rather than continue operating it. There were NO Engine or warning lights indicating low oil. The vehicle is currently awaiting diagnosis by Kia under the 10-year/100,000-mile powertrain warranty. I am concerned that the presence of metal in the engine oil indicates an internal engine component failure that could result in sudden engine seizure, loss of propulsion, or other engine failure while the vehicle is being operated in traffic. There was no crash, fire, or injury associated with my vehicle at the time the problem was discovered because I stopped operating it after being advised not to drive it. The vehicle also has significant premature paint delamination on the roof. Large areas of the original factory paint have separated/flaked away from the roof despite the vehicle being approximately six years old. This is not isolated rock chipping or normal cosmetic wear; it appears to be a widespread failure of paint adhesion. I am concerned about additional paint separating from the vehicle while traveling at highway speeds and potentially becoming airborne, as well as the long-term effect of exposed roof metal and corrosion. Kia has been notified of the paint condition but has declined to repair it.

This started in July/August. I went in to get into my car and noticed that although my car was making the sound of unlocking, it wasn’t unlocking. Neither the key fob or pressing the button on the door handle would unlock my car. I manually used the key to get in. Once I got in, I had a rear collision warning on my dash and was unable to shift from park. I overrode the shift mechanism and took it to a mechanic. They hooked it up to a reader and was tracking down the error when all of sudden the error code disappeared, and they were unable to progress. I left there and drove to work without issues. Two days later (Saturday) it happened again. I disconnected the negative battery cable and waited a few minutes before I hooked it back up. It was fine for about a month and then it started happening again. This time I tried the battery cable again and it worked for a while, but it started to happen more regularly. I took it to a Kia dealer but they were unable to replicate it. They said if it happens again record it and send a the video. Two days later it happened, and I sent them a video. I took my car back to the dealer and it has been there 11/9. In between visits, it happened, and I overrode the shift mechanism and I noticed my dash lights were almost out as well as the other issues. I believe I know what the issue is. I noticed this only happens when it’s cool in the early morning and then, when the sun comes up, there is an abundance of moisture on the inside windshield. I believe that heavy moisture is shorting out the electronics in my dash. I’ve never had an issue when it rains or midday. It’s probably why this has been so noticeable in the fall early winter. We have lots of mornings in the 30’s and they quickly warm up when the sun comes out. I have read some online forums that talk about the condensation issue with the Kia Telluride. I haven’t found any that talks about the electronic issue however.

I am reporting a potential safety defect involving excessive engine oil loss and persistent oil leakage on my 2020 Kia Telluride, VIN [XXX]. The vehicle currently has approximately 100,367 miles. It has been experiencing significant oil loss, approximately one quart of engine oil per week. I am concerned that this amount of oil loss is abnormal and creates a potential safety hazard if the engine loses sufficient oil while the vehicle is being driven. The vehicle has also had repeated oil leaks, including an oil pan leak and timing cover leak. I have taken the vehicle to Kia for repairs multiple times, but the oil-related problems have continued. This has required me to continually monitor and add engine oil to prevent the oil level from becoming dangerously low. I specifically brought the vehicle to Kia because of the excessive oil consumption and ongoing leaks. However, the dealership has told me that they will not perform an oil-consumption test until the existing oil leaks are repaired. Kia Customer Care also opened case #[XXX], but I was subsequently told that Kia could not provide assistance because the vehicle is outside the standard warranty period. I am concerned that the underlying cause of the excessive oil loss has not been properly diagnosed. I am also concerned about the possibility of engine damage or engine failure if the vehicle continues losing oil at this rate. Kia has also issued a 2026 warranty extension concerning an engine oil-filter-housing gasket leak on certain 2020–2025 Telluride vehicles. I have asked Kia to determine whether my vehicle is affected by this condition and whether the current oil leaks are related, but I have not received a satisfactory resolution. I am asking NHTSA to review this complaint along with other complaints involving 2020 Kia Tellurides experiencing excessive oil consumption and/or recurring engine oil leaks to determine whether there is a potential safety defect or broader pattern that warrant INFORMATION REDACTED

On October 1st, 2022 we rented the listed vehicle from Budget rent a car in Port Canaveral, Fl. We had just returned from a cruise vacation and due to the hurricane, we had to drive to Fort Myers to pick up my 83 year old mother from the hospital, as my sisters home had just been flooded my Hurricane Ian. When we rented the vehicle, the location was extremely busy, and they simply handed us the keys to the car. No inspection was completed, however my husband and I noticed several dents and deep scrapes to the vehicle that had began rusting. We joked how bad in shape the vehicle was considering it only had about 5000miles on it. We drove to Fort Myers and heard some banging in the rear drivers side. When we stopped for gas, my husband checked to make sure there wasn’t any obvious issue with the tire….he noted no appearance of damage to the tire. As no other vehicles were available due to the hurricane, We continued, picked up my mother, and began our trip back to the north Atlanta. We spent the night in north Florida, and resumed our trip the next morning. In Forsyth, GA (Monroe county) the rear tire began to wobble and the car began to shake. Traffic was extremely heavy, but we were able to pull to the narrow shoulder. My husband got out of the car and immediately noticed the tire appeared to be coming off the car. He looked at the lug nuts and only 3 remained. He touched them to see if they were tight and 2 bolts with the nuts attached fell off the wheel. The BOLTS fell off the wheel! We contacted Avis budget group and explained the situation, but we’re told it would be 4 to 6 hours before they could send anyone to help us. We pleaded with them, as this section of highway is extremely dangerous and full of semi-tractor trailers. We had to call 911 to get help to get us to safety. Additional info available. We have the lug nuts/broken bolts in our possession. Clearly we were rented a defective, not maintained, unsafe vehicle.

On [XXX], my Kia Telluride received a warranty engine replacement at Greenway Kia East in Orlando, FL. Just two days later, on [XXX], the engine overheated while I was driving with my young child. The temperature warning light came on. I stopped immediately and opened the hood — there was no coolant in the system at all. This failure occurred immediately after a major engine replacement, suggesting that the dealer failed to fill or properly check the coolant system. I was left stranded near a daycare and had to call a third-party tow truck because Kia roadside assistance estimated a 90–120 minute wait. This put my child and me in serious danger. Despite the dealer’s clear negligence, I was sent an invoice for $1,833.77, blaming me for the damage. Upon retrieving the car on May 31, 2025, I personally checked under the hood — the coolant level was still below the MIN line. When I pointed this out, the service manager said, “We’re not required to top it off, but if that satisfies you, we’ll put some in.” This is extremely unsafe and irresponsible, especially after a critical repair like an engine replacement. Later, the dealership even claimed to Kia America that the engine was not replaced under warranty, contradicting their earlier confirmation. This kind of conflicting information, combined with unsafe practices and disregard for basic safety protocols, raises serious concerns about consumer safety and the dealership’s integrity. To make matters worse, Kia America closed my case ([XXX]) on June 10 without notifying me or giving me a chance to respond. I received only one dropped call from an unknown number, and no voicemail or follow-up communication. A formal complaint was mailed to Kia America on June 11, 2025, and I am currently waiting for their response. On June 12, 2025, I also filed a complaint with the Better Business Bureau (BBB). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am the original owner of a 2020 Kia Telluride with 48,409 miles. My wife purchased it new. It has never been sold or transferred. It is fully covered under Kia's 10-year/100,000-mile Powertrain Warranty. What component failed and is it available for inspection? The engine is consuming excessive oil due to failed internal components—likely the piston rings. This has fouled the spark plugs and caused active misfires on cylinders 1,3,4,5. Codes: P0300, P0301, P0303, P0304, P0305. Kia acknowledges this defect in TSB ENG222, which defines consumption over 1 quart per 1,000 miles as abnormal. The failed components remain in the vehicle and are available for inspection. Has the problem been confirmed by a dealer? Yes. [Dealer Name] confirmed the misfire codes and excessive oil consumption. Despite being original owners with an active warranty, they refused to cover the repair. The advisor said they "only cover internal engine parts"—which is exactly what is broken. We were sent home with a flashing check engine light. Has it been inspected by manufacturer or others? No. Only the dealership. Kia Corporate has not inspected it. How was safety put at risk? A solid check engine light means active misfire and risk of sudden engine stall or seizure. Other Telluride owners report complete power loss on highways and intersections—no acceleration, no power steering, no power brakes. My wife and children drive this car. I fear for their safety every time they start the engine. Were there warning symptoms? Yes. Two weeks before the check engine light appeared, I noticed a slight shudder during acceleration that gradually worsened. The light came on solid, then began flashing within days. No oil light appeared. No other warnings. Kia advertised a 10-year/100,000-mile warranty. At 48,409 miles, they denied coverage for a known, documented defect. That is not a warranty. Not true. I request an investigation into the 2020 Telluride 3.8L engine. Thank you

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The panoramic sunroof glass spontaneously failed while the vehicle was being driven on the interstate at approximately 70 mph. A very loud bang, comparable to the sound of a gunshot, was heard from the roof area. After safely pulling over, we observed that the sunroof glass was bowed upward/outward and had a large crack extending from the driver’s side toward the passenger’s side and toward the front of the vehicle. The glass remained intact within the sunroof frame but was visibly damaged. The vehicle and sunroof assembly are available for inspection upon request. The damaged sunroof glass should also be retained and made available for inspection, if possible. 2. How was your safety or the safety of others put at risk? The failure occurred unexpectedly while traveling at approximately 70 mph on an interstate. The sudden, extremely loud bang startled us and created an immediate safety concern while the vehicle was traveling at highway speed. The sunroof glass also bowed significantly upward and developed a large crack. An unexpected failure of overhead glass while traveling at highway speed presents a potential safety hazard to the occupants. We were also concerned about the possibility of glass breaking further or pieces of glass becoming detached and creating a hazard for the occupants or other motorists. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? At this time, the failure has not been reproduced or independently confirmed by a Kia dealer or independent service center. The damaged sunroof is available for inspection. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? To date, the vehicle and sunroof failure have not been inspected by the manufacturer, police, insurance representatives. A claim has been submitted to insurance company.

We purchased a new 2020 Kia telluride in late 2019. We purchased this vehicle because of its 100,000 mile warranty. We went the extra step and added the best extended warranty possible so we were covered for many miles and years. I have always done my own oil changes as I am a journeyman fitter and understand the mechanics of a vehicle. I kept every receipt from every oil and oil filter purchase for the last 5 years as well as a detailed log book. Around 75,000 miles we started noticing major oil consumption. Approximately 1 quart every months and then up to about a quart every 2 weeks. We also notice a huge loss in engine power and take off. My wife said she was having trouble pulling out onto hills and was very dangerous at intersections, because of the lack of power. We then took the Kia telluride to my main mechanic, he replaced all 6 spark plugs and said we should immediately take it to a dealer as it sounds like the timing chain maybe going bad. This was early August 2024. I made an appointment with Diehl Kia in hermitage the next day for [XXX]. After a few days the dealer called and said that they could not get the car to replicate the noise they heard when they brought it in. It sat for 2 weeks before they decided to open a claim with Kia customer service. Kia recommended they do an internal investigation at the customer cost which we approved. They said they had found some build up and Kia was requesting the oil change records which I promptly provided. Kia then recommended to do a compression test on the cylinders. Again at customer cost. Even though the vehicle has less than 100,000 miles and the warranty is still valid. We agreed to pay for the compression test as well. After a few more days the service associate called me and said that the compression test had passed to my surprise. A few more days went by and we really had no answers. After pressing the dealer for answer they finally told me that Kia was not accepting our service records.

After a few months from purchasing (9/2022), I noticed some weird electrical issues occurring. The first thing I noticed was that sometimes the rear wiper blades would turn on automatically when shifting in reverse when the wiper blades were off. I would turn the rear wiper blades on then off repeated times until they finally stayed in off mode. As time went on, then the drivers side window would roll down automatically after starting the vehicle, and it would not shut all the way after pressing the button. I would have to hold the up button when turning the engine off, just so the window would remain completely closed when parked. Sometimes, this would continue for a week or more...then it would go back to normal for a few months. These issues would continue and others started to arise such as the check engine lights, low battery etc. appearing while starting the vehicle. Sometimes it would say that the engine is on, when it wasn't...so I would hear a warning signal when trying to leave the vehicle with my key fob. I would have to press the stop engine button and wait for it to say that the engine is off. This evolved into the car struggling to start...with a repeated clicking noise being heard. All warning and hazard notifications appear on the main screen and the driver's side window rolls down by itself and it takes 5-7 minutes for it to start, but eventually does. This has been going on now for since March of 2024...so it's not a battery issue, or a starter issue...but based on the nature of these malfunctions...it is electrical issues...which can pose a serious safety threat...especially with a potential electrical fire. What are our options for a potential manufacturer recall? As of this writing, it took roughly 20 minutes to start my vehicle, as it is very cold in Rochester, NY. I recently had my vehicle fully serviced (8/25) and it wasn’t acting up at the time so they couldn’t pinpoint any electrical issues. I took videos of the incidents.

My 2020 Kia Telluride experienced progressive and severe engine oil consumption that ultimately required a full engine replacement. Beginning well before the failure, the vehicle required frequent manual oil top-offs between scheduled changes, including on longer trips. No low-oil warning light, check-engine light, or oil-pressure warning ever illuminated to alert of critically low oil levels. In late March 2026 an independent service center replaced the engine oil filter housing and related gasket after an oil leak was observed; an axle damaged by oil spray was also replaced at that time. Shortly afterward the manufacturer issued a warranty extension covering oil-filter-housing gasket leaks on 2020–2025 Tellurides, extending coverage to 15 years/180,000 miles for that specific condition. Despite the housing/gasket repair, the excessive oil consumption continued. Several weeks later the vehicle lost power and broke down while being driven. It was towed to an authorized Kia dealership. Technicians inspected the vehicle, confirmed heavy oil consumption (noting the engine had been requiring large amounts of oil nearly weekly with no external ground leaks observed), and diagnosed catastrophic internal engine damage. They recommended complete engine replacement at a quoted cost exceeding $13,000. The dealership also inspected the oil-filter housing area under the recent warranty extension but determined the engine damage itself fell outside that limited coverage. The oil-consumption problem and resulting engine failure create a clear safety risk: sudden loss of power or stalling can occur without any dashboard warning, potentially while the vehicle is in motion on public roads. The failed engine and related components remain available for inspection. The condition has been confirmed by both an independent service center and an authorized Kia dealership. Similar oil-consumption and engine-damage reports have been widely noted among other owners of the same model.

My 2020 Kia Telluride has undergone three separate oil consumption tests through an authorized Kia dealership. Each test confirmed abnormal oil consumption, yet Kia declined to take corrective action beyond temporary monitoring. The issue has continued to worsen. The engine is now burning oil on the piston, and I am required to check my oil level daily and add oil weekly, even after a fresh oil change. This is not routine maintenance — it is a direct result of a defective engine design that is unable to properly retain or burn oil within acceptable limits. Because the oil burns so quickly, the oil light can appear unexpectedly while driving, creating a dangerous situation if the oil level drops too low. This poses a serious risk of engine seizure or power loss, which could lead to a crash or leave the driver stranded on the road. Manufacturer Response: Kia has acknowledged that the vehicle has a confirmed oil consumption issue but has refused to replace the engine because it is outside of warranty coverage. Instead, the dealership advised me to trade in the vehicle and purchase a new Kia, which is not an acceptable solution. When I questioned this suggestion, I was told that Kia could not guarantee the new vehicle would be free of oil consumption problems because the issue is related to the engine design itself. In other words, Kia is aware of a recurring engine defect but is not providing a remedy for affected vehicles. This is a manufacturer defect that should not be dismissed due to warranty expiration. The repeated documentation of abnormal oil use demonstrates that this problem began long before the warranty period ended. This defect represents a serious safety issue for the following reasons: 1.Risk of engine failure: The Telluride can lose oil rapidly, causing the engine to seize or stall while in motion. 2.Fire hazard: Burning oil within the pistons increases the risk of internal engine fire or smoke. 3.Environmental impact: Constantly burning oil .

When starting the vehicle to warm up (in colder temps) it made a squealing noise and slowly faded. Returned to drive the vehicle and there was a puddle of oil underneath. Upon inspection, it appeared that the leak was coming from between the (plastic) oil filter housing and the engine (it's connected to. This causes a concern as it could cause my engine to seize while driving (especially on freeways). Causing a collision risk and destroying the cars engine at the same time. When researching I found that this is a common (cold temp) issue among Telluride's. I attempted to call Kia service at least four times with no answer/no call back. On my fifth call attempt I was routed to the parts department and found that the part is and has been on backorder for some months now. Was told that there are over 3000 on back order to the states, all accounted for. I researched the issue and found various Kia Telluride forums stating the same cold weather temp issue. This is obviously not an isolated case with no one (O'Reilly, Auto Zone, Advanced Auto & the dealership) having the part in stock and over 3,000 other cases awaiting their back-ordered part. Previous to this, I attempted to get an oil change at a local lube shop and was advised that they could not do an oil change on my vehicle because there was an issue with the oil drain plug and the oil pan seal circulating with the local live shops. They would be unable to do my oil change unless I sign a waiver stating they're not liable for anything that occurs after the oil change occurred. I am attempting to make an appointment now, however with all the parts on backorder (for months now) the only thing I can do is to not drive my vehicle until their is a stockpile of parts available to alleviate this malfunction. This issue has not been investigated by insurance or authorities as I'm uncertain that this falls within their wheelhouse. Recently my check engine light came on, I had the code checked it was the thermostat.

OCTOBER 2024 Before the main incident Oct 2024, I started noticing slight changes in the way my KIA was operating: - Delayed response to accelerate when at a light - Tire sensors/ crash collision sensors - Lane assist pulling my off the road or into on coming traffic (random) - Intermittent Power loss while driving. - Lights not working properly. - High beams failed to operate in Sept and was told by Burlington WA KIA there was not a fix for the recall, while there for service/oil change. - Car going into parking brake when not activated. - When stopped in car is in drive, when starting to accelerate the car went in reverse causing me to hit a stump and partially tearing front bumper off. About a week after that incident I was driving home from store and car started randomly pulling car into oncoming lane. Thankfully there was not a vehicle at that time. Car then started having weird fluctuations with speedometer and dash info. Went from 24.7 miles to gal to 38 and kept jumping, experienced more instances of power loss while in drive. Then all of sudden dashboard went haywire. Whole dash lit up and was switching from different drive modes. I started noticing an electrical burning smell and smoke coming from hood. I pulled over not even a mile from home and started to pull everything important from vehicle. Think the car was on fire under the hood. After several minutes of accessing the situation and smoke dissipated, I decided to try and get car home. As I put car in drive it again went in reverse. I put car in park again and then drive and was able to proceed and limp car home. I parked car and took video of the dash light party and video of putting car in drive and it changing randomly. There still was an electrical burn smell on outside and in cab of vehicle. When my husband arrived home I tried to start vehicle to show him and it wouldn't start. So, he thought maybe the battery fried and took bat in to Napa and bought a new battery.

The argument for the warranty claim to be honored and the work to be completed is as follows. Kia Inc may not want to take responsibility for the engine. They may want to shy away from their duty by claim negligence on the part of the owner. Kia will ask the car owner to produce every receipt and service record you can scrape together just to prove that one was not done at an “authorized” center of some sort. Or they will argue the distance between intervals of oil change down to the smallest of detail to claim you abused the engine. An engine they know has a flaw. An engine with a ring flaw across multiple lines, years and models. That in multiple lawsuits they have in fact taken responsibility for and lost in cases so they are aware of the issue. But my argument is not necessarily these things. My argument is the oil warning light. That light is the real danger when combined with this fatal engine flaw. For a **3.8L V6 gasoline engine** (like that of the 2020 Kia Telluride) using **SAE 5W-30 motor oil**, you can theoretically determine the oil loss level that would trigger a warning indicator based on the overall oil capacity and typical safety standards. Oil Capacity and Warning Indicator Calculation Specifications of My 2020 Kia Telluride according to Anthropic AI. - **Oil Capacity**: 6.9 quarts - **Typical Safe Operating Level**: Generally, engines are designed to alert drivers when oil levels drop to about **1 quart** below the full capacity, which is critical to maintain proper lubrication. Oil Loss Threshold- - **Full Capacity**: 6.9 quarts - *Warning Threshold*: -*Safe Level*: 5.9 quarts (6.9 quarts - 1 quart)Safe Oil Level - The warning indicator would typically come on when the oil level falls to approximately **5.5 to 5.9 quarts.This range ensures the engine continues to operate safely without risking damage due to inadequate lubrication.Key Aspects of FMVSS 101 Regarding Oil Pressure Warning Lights. S5.2.3. (The light must alert the driver...

About a few weeks ago my family and I were on our way to Disney for vacation. While on the highway driving around 70+ mph the vehicle suddenly made a big bang sound. The radio shut off and the checkESC (electronic stability control) message popped up on the display. A few miles later it did the same thing. Good thing we had just started our 10 hour drive to be able to take a back road back home doing 55 mph to switch vehicles. Once we got back from our vacation, we took it to a Kia dealership. On our way to the dealership the radio was constantly rebooting itself and then the big bang will happen. The dealership said they could not duplicate the issue and fixed the recalls instead and called us to come pick the car up. On our way home from the dealership, the radio again started rebooting itself. We tried to take it to an Hyundai dealership because it’s a lot closer to our house, only to find out when we got there that they don’t have the equipment to electrically work on a Kia product. So on our way home from the Hyundai dealership the radio starts doing the same thing and while going over an overpass, it did the bang thing twice. The bang feels like the car is stopping and starting back up really fast while the car is in gear and rpm’s jump up as well. It all starts with the radio constantly rebooting itself nonstop. As of 6/10/23 the car is back at the Kia dealership. After explaining and showing recorded videos to the service advisor, they claim the car cannot possibly be repaired unless they are able to duplicate the issue. They think we have an issue with the radio constantly rebooting itself, which we do, but it’s more so of a safety issue of the car shutting itself off while driving. We purchased this vehicle 2 months ago and have put less than 2500 miles on it. Also the other day, we were pulling up to our home and when I put the car in reverse to back in, the car shut off. This has to be the worst purchase we have made. It only has 54,000 mikes on it.

My 2020 Telly has a random vibration. When it appears it can be felt throughout the vehicle. Just as quickly as it appears it disappears. Mostly felt with acceleration/when changing gears (right after). Also there have been a handful of times I've attempted to go from a stopped position or pulling into traffic and the car just sits there. It does not rev or increase rpm's, it does nothing. Then after about 2 seconds it will just calmly go as if I had just pressed on the gas. This is very scary when it happens while pulling into traffic or attempting to cross over traffic... Because when it does start to go you are now 2 seconds behind where you should be and I was almost hit. Had a similar issue with my Tucson and Hyundai fixed it ASAP.. it was the transmission clutch. Also having an issue with my CV axle/joint/boot. It's leaking but it is not broken or cracked etc. It's just leaking and spitting greas/fluid all over the wheel etc. Trying to find a part for it that is not at the dealer is not easy but the dealer wants 400 just for the boot (not installed). This is ridiculous and price gouging. Check the Kia forum and you will see many people with these same complaints/concerns that need to be addressed BEFORE someone gets hurt. Having your vehicle not go while pulling into traffic is SERIOUS.. fix it Kia! I have 2 shops that have confirmed there's an issue, felt vibration, picture of leak, instead what's up with the transmission AWD but is believed to be driveshaft/transfer case related. 64,440 miles currently. Issues started at 62,261.. also I contacted crown Kia(st. Pete FL) regarding windshield replacement because I have a crack that is growing after repair. I have the letter (customer and dealer regarding cheap glass "Goodwill repair" and they knew nothing about it. I produced the letter and have heard nothing from them. Dealerships hate doing anything that won't bring a dollar. KIA FIX MY ABILITY TO SAFELY GO IN TRAFFIC PLEASE. SAVE LIVES PLEASE NOW THANK YOU

Vehicle manufacturers have certain basic rules and procedures that must be followed. When a vehicle manufacturer sells a vehicle, it has a duty to ensure that the vehicle functions properly and safely for its advertised use and is free from defects. When a vehicle manufacturer discovers a defect, it must explicitly disclose the defect and make it right or cease selling the vehicle. When a vehicle manufacturer provides a warranty, it must stand by that warranty. I believe Kia has breached its duties and rules as follows. Specifically, these Class Vehicles (Tellurides and Others) have malfunctions regarding their incorrectly manufactured piston oil rings which can result in engine damage and failure, and even potentially cause a fire known internally and secularly as an ("Oil Ring Defect”). Now, I purchased this car in January of 2023. Based on Kia’s active and persistent promotions touting the quality of its vehicles and my partners admiration of Kia vehicles, we considered Kia a quality company with a strong reputation for producing reliable vehicles. In addition to Kia's reputation through its marketing and promotion. We decided on the 2020 Kia Telluride because we believed it was a high-quality vehicle, after a salesman convinced us that the vehicle was highly reliable and came with great technological features. Since purchasing this vehicle it has only taken the vehicle to the certified dealership for its routine maintenance as recommended by both the vehicle alert system and the Service Department at Courtesy Kia. However, through all our consistent visits to dealerships, we had never been told of any recalls or defects related to his vehicle’s oil ring system. Since 2015, KIA has designed, manufactured, distributed, sold, and leased the Class Vehicles with this problem. As discussed earlier and in more detail below, the Class Vehicles contain a defect that causes a serious safety concern. The unresolved defect with the Telluride engine is an attack on owners.

A continuation from my last post. I brought my car back to the dealer.The worker came out to inspect my car and he lifted the hood and he said I had a loose negative battery cable and that I had the wrong battery in my car. He said that might be the cause of the flickering lights.My car was at the dealership for three days before I was called to come pickup my car.He stated they found another service update that my car needed P0471 and that cleared my check engine light and the battery he said once again I have the wrong battery in my car and they were only able to tighten the negative cable so much.I explained to him that it was the correct battery because I went to Walmart where the battery was purchased and they auto manger printed out that paperwork that shows it is the correct battery for that car.Then he had me sign for my car and I left.While driving home my battery light stared flickering again.So I called him and said I thought you were able to tighten the negative cable to the battery. He then said they did the best they can do because it is the wrong battery.After he got off the phone all my lights on my dashboard lit up.My car seemed possessed.My steering locked up and brakes were not working.Scared and crying i called him back and was telling him what was happening to my car.He said once again it was due to battery. Crying I said I'm scared what do I do?He advised me to put my car in netural and try to pull off to the side.I explained to him that I was on the freeway in 5pm traffic my hazards, signals and brakes aren't working.I then asked him what do I do once I can stop the car.Do I bring it back to the dealership? He said the only thing they can do if i bring it back is to have me buy a new battery.At this point the car completely turned off.I was able to roll off the freeway then my car stopped completely violently as if someone slammed the the brakes.Now they want me to buy a new alternator and transmission.Car had no issue before taking it in.

Our vehicle was flagged for a service campaign recall for the power seat control switch and seat slide knobs. According to the service campaign, the power seat switch back cover can be dislodged resulting in an internal misalignment of the seat motor control switch in certain conditions. When taken to the certified KIA dealership for repair on this recall, we were told the service campaign recall ONLY applied to the passenger side front power seat. The dealership therefore only made the repair to the passenger side seat. Less than 6 weeks after this repair (in Nov 2024), we discovered the driver side power seat stopped functioning in the reverse position. We could move the left driver power seat forward, but the seat would not move backward. This became a significant safety issue as once a shorter person drove the vehicle, a taller person had no means to move the seat aft to safely allow sufficient space for legs/feet on the gas/brake pedals. All other seat position functions worked normal, except for sliding the seat aft on the driver side. It simply would not move aft. The car became unsafe to drive for taller individuals and we had to take it back to our dealership to repair at our cost. The KIA dealership verified the seat failed to move in the aft position and they replaced the driver side switch assembly. The recall campaign details seemed to match the symptoms we had on the driver seat; however, our vehicle VIN only correlated the campaign to the passenger side, NOT both seats. The KIA service manager informed us to contact KIA Customer Care as he felt both seats should have been part of the recall given our issues. KIA Customer Care took note of our issue, but said there is nothing they can do since the recall was only specific to the passenger side of our vehicle. We hope this issue can be resolved for future Telluride owners who may have similar problems given KIA would only repair (as part of the recall) the passenger side & not both seats.

**1. What component or system failed or malfunctioned, and is it available for inspection upon request?** The engine failed catastrophically and caught fire while I was driving. The vehicle was towed to the Kia dealership, where it remains available for inspection upon request. **2. How was your safety or the safety of others put at risk?** The engine suddenly caught fire while I was driving, creating an immediate risk of a serious crash, injury, or death to me, my passengers, and other motorists. I had to pull over immediately, and the fire department responded to extinguish the fire and ensure everyone's safety. **3. Has the problem been reproduced or confirmed by a dealer or independent service center?** Yes. The Kia dealership inspected the vehicle and confirmed that the engine has failed and requires replacement. However, they attributed the failure to "engine wear and tear" despite the vehicle having only approximately 111,000 miles and having been regularly maintained according to Kia's recommended maintenance schedule. Two months before the failure, the same dealership repaired an engine oil leak, and they have been unable to explain why the engine failed and caught fire. **4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others?** The vehicle has been inspected by the Kia dealership. The local fire department responded to the vehicle fire at the scene. At this time, the vehicle has not been inspected by the manufacturer or any other parties. **5. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear?** Approximately two months before the engine failure, the engine warning light illuminated due to an oil leak. I immediately took the vehicle to the Kia dealership, where they repaired the oil leak at a cost of approximately $3,000. After the repair, there were no warning lights, messages, unusual noises, or other symptoms before

Subject: Ongoing Issue with Excessive Oil Consumption – 2020 Kia S V6 To Whom It May Concern, I am writing to formally express my concern and frustration regarding a recurring issue with my 2020 Kia S V6 related to excessive oil consumption. Despite multiple visits to the dealership and attempted repairs, the issue remains unresolved and continues to affect the safety and reliability of my vehicle. Vehicle Information: Year: 2020 Make: Kia Model: S V6 VIN: [XXX] Current Mileage: Approximately 85,808 miles Timeline of Events: September 6, 2024 – Oil change completed at Kia dealership in Easton. No prior issues reported at this time. [XXX] – After about a week of shaking and stuttering during acceleration, the vehicle shut off completely at a stoplight. Upon checking, the oil level was found to be empty. I added 6–7 quarts of oil. No oil warning light appeared on the dashboard at any time. January 14, 2025 – Brought the vehicle to the Easton Kia dealership. Diagnosed with a broken and leaking oil filter housing, which was replaced. Another oil change was completed. [XXX] – After the engine light came on, I checked the oil at 77,021 miles and found it to be low again. I added 1 quart of oil. The engine light was later determined to be due to a loose gas cap. Once again, no oil warning light appeared. [XXX] – At 78,000 miles, I checked the oil, as advised by Kia, to monitor consumption. The oil level was completely empty. I added another 6–7 quarts of oil. No warning light appeared on the dashboard. [XXX] -- Kia for oil change and consumption test at 82,177 miles. Consumption was read after 1,000 miles and I was advised it was good. I was told to come back at 86,075 miles as per Kia recommendation. [XXX] -- A few hundred miles before the deadline, at approx 85,790 miles I checked oil before a trip, it was empty. Again, no warning light came on the dashboard to warn me of low/no oil. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(

We contacted Kia US after taking the Kia Telluride to a Kia service station for an oil change.The service tech told us that they were not going to do an oil change because,”the Telluride was a ticking time bomb.” This was said in front of the Kia service Mgr.We were very nervous driving the vehicle because no one explained what that meant.Shortly after the service appointment, the Telluride’s engine caught on fire.We call Kia US that same day to open up a case.We explained all the issues we had with the Telluride (windshield issues, headlight issues, main display screen issues, luggage rack issues, sunroof, drive shaft, wiper fluid filter issues), to include the engine. After paying an attorney to provide all documents that Kia US requested from us, including every oil change receipt for the Telluride, Kia US only offered to only pay for the parts for the driveshaft/engine fire issues. To make matters worse, the Kia service department said that the 100+ parts needed to repair the engine, were on back order. Our Telluride’s engine caught fire in April and Kia US has done nothing for us, even though the issues are under 2 recalls. This is unacceptable for a manufacturer to ignore recalls, especially when it comes to the safety of people, families and children. We contacted Kia US for 6 months with no help from them. We sent registered/certified letters to Kia US executives, legal Dept, Kia Finance and the last communication from Kia US was that they are not doing anything for us- no repairs for the recalls, even though we mentioned the recalls associated with our Vin/Telluride. They are completely disregarding the entire situation. Since then, we have had to find another option for transportation since we have been without the Telluride for 6 months. Kia US needs to take back the Telluride and either provide us with a safe/working vehicle or reimburse us for what we have spent on the Telluride. Thank you for your assistance. Sincerely, [XXX] [XXX] INFORMATION REDACTED

On [XXX] , my wife heard a rattling noise while driving. I verified the rattling noise on [XXX]. On [XXX], I researched online and there are a lot of 2020 Telluride owners that experienced the same issue. They mentioned they had no oil in their cars. I checked the oil that morning and confirmed my wife's car had no oil. I reviewed the manual and checked the oil again according to the instructions in the manual. The car still registered no oil in the dip stick. The car did not report any warning lights. There was no engine light or oil pressure light that came on at any point in time to indicate there was no oil in the engine. Per the instructions in the manual, I drove the vehicle carefully to the auto part store. I purchased and added 6 quarts of synthetic blend 5W 30 oil. After that, the rattling in the engine seized. I sent a text message to Kia in Alpharetta, GA. I spoke with Izzy and explained the situation and requested an appointment to have an oil consumption test performed. She advised that the oil consumption test had a $440 cost and consisted of performing a series of oil changes over the course of a specified time to determine how much oil the vehicle was burning/consuming. She said I could call consumer affairs and I asked her if she was referring to Kia consumer affairs or the national/federal consumer affairs. She verified it was the national/federal consumer affairs and provided me with this number to call 1-888-327-4236 which actually belongs to Kia's consumer affairs hotline. Izzy advised that I had pending recalls in my car and asked why I have not brought the car in. I mentioned that I live in Ball Ground, GA and the nearest Kia dealership to me is the one in Woodstock, GA. However, I stopped taking my car there because I previously took the car there to get the oil changes done and each time I did the car would have a nail in one of the tires a couple days after the service. I lost confidence in the dealership. INFORMATION REDACTED PURSUANT TO T